lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-21-2011, 05:42 PM   #1
johneich
Not Yet Wild
 
Join Date: Feb 2011
Posts: 34
Default Clutch slipping? G9

My clutch was rebuilt five years ago, just in the last few days the engine noise is louder and it does not seem to have the same "pick up and go", I have never serviced it, is there service to do? What can I troubleshoot?

John
johneich is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-21-2011, 07:20 PM   #2
sho305
Vegas modded 420
 
sho305's Avatar
Yamaha
 
Join Date: Jun 2009
Location: West MI
Posts: 15,433
Default Re: Clutch slipping? G9

On a G9 there is a grease fitting on the outside edge, but don't put over 2 pumps in it and make sure none comes out on the belt. On rear side near ramps of rear clutch is another fitting put a couple in that, check the plastic shoes on the ramps while you are in there. I you want to do it all take the cover off the engine clutch and check all the weights and links, then lube the pins it moves on with a little super lube spray or light oil, not much, clean any excess, replace cover, clean it with brake clean first if you need to inside there (also spray off inside the spring in rear clutch if you need). The links and weights are usually what wear out in there. The grease fitting is for the center bushing.

The belt is worn out when it gets down to 1" wide, if lifted you should replace it before that. 1 3/16" wide is new size.

Last also check the aluminum sheaves on both clutches when they wear out they wear holes right through them, and then chew the belt up and eventually they break off.
sho305 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
Driven clutch slipping Gas EZGO
1998 Yamaha Clutch slipping Gas Yamaha
EZ GO workhorse 02 ST350 clutch slipping Gas EZGO
Drive Clutch slipping Gas EZGO


All times are GMT -5. The time now is 07:41 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.