lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 09-02-2010, 12:14 PM   #1
ky_mike
Gone Wild
 
ky_mike's Avatar
Yamaha
 
Join Date: Aug 2010
Location: Kentucky
Posts: 207
Default Yamaha G1 starter generator test

Just throwing this out there for anybody like me that didn't know how to test a starter/generator. This is how I tested mine and there may be other ways to do it, but this ended up being pretty simple.



First off there are 4 posts on the starter each should be stamped A1, A2, F1 and F2 as in the diagram above. There should also be a green wire and a red wire coming out the side of the starter. I disconnected all cables and wires prior to testing.

Connect post F2 to the positive terminal on your carts battery and A1 to the negative terminal. Now if you connect A2 directly to F1 your starter should spin forward.

For reverse connect F2 to positive terminal of battery and A2 to the negative terminal. Now if you connect A1 directly to F1 the starter should run in reverse.

The last thing I did was check the Ohms running through the red and green wires. To do this use a voltmeter set to Ohms (looks like an upside down horseshoe symbol) touching the green wire with one probe and the red wire with the other you should read about 5 Ohms.

Hopefully this will save you some time if you were wondering if your starter was bad. Took me a while to figure out on my own without a repair manual.
ky_mike is offline  
 
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
is it the starter/generator Gas Harley Davidson
88 starter generator bench test Gas EZGO
Starter/Generator Gas Club Car
Yamaha G1 complete motor with generator/starter Gas Yamaha


All times are GMT -5. The time now is 07:09 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.