|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-18-2020, 06:19 PM | #1 |
Not Yet Wild
Join Date: May 2020
Posts: 6
|
98 gas club car surges and backfires
Hello all
I have a 98 gas club car that while driving it will randomly drop speed quickly then pick back up normal. It doesn’t do it all the time and will go through spells where it is worse. Sometimes as it surging it does backfire but not every time. Thoughts and thank you! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-18-2020, 07:28 PM | #2 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,673
|
Re: 98 gas club car surges and backfires
How fast are you going when it happens? Sounds like you've got the governor spring zip tied too tight and its hitting the rev limiter
|
05-18-2020, 07:41 PM | #3 |
Not Yet Wild
Join Date: May 2020
Posts: 6
|
Re: 98 gas club car surges and backfires
I have the throttle all the way down. I will try half speed tomorrow and see if it happens. I did first notice it going downhill but seems to do it regardless of grade.
|
05-19-2020, 05:23 PM | #4 |
Not Yet Wild
Join Date: May 2020
Posts: 6
|
Re: 98 gas club car surges and backfires
Today I drove the cart at full throttle until it started to surge again. Then just let off the throttle just slightly and it seemed to run just fine. I also put it in maintenance mode and applied full throttle. During this time time the throttle on the engine was pulsing.
Thanks for the help |
05-19-2020, 07:27 PM | #5 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,673
|
Re: 98 gas club car surges and backfires
Do you have a zip tie on the governor spring? If so loosen it just a bit and you should be fine
|
05-19-2020, 08:26 PM | #6 |
Not Yet Wild
Join Date: May 2020
Posts: 6
|
Re: 98 gas club car surges and backfires
No zip tie on governor. I couldn’t figure out how to upload videos to the forum. Below is a link to a google drive with two videos. One with throttle all the way down and the other (after i got it stable) at 90% or so throttle.
https://drive.google.com/drive/folde...B1zFKzT4mbZybs Thanks |
|
|
Similar Threads | ||||
Thread | Forum | |||
99 club car ds 48v surges | Electric Club Car | |||
Club car surges | Electric Club Car | |||
Club car surges and no forward | Electric Club Car | |||
2010 Club Car Surges at low speeds | Electric Club Car | |||
2003 Club Car DS Bucks and Surges at First GO | Electric Club Car |