|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-13-2017, 08:18 PM | #1 |
Not Yet Wild
Join Date: Jun 2017
Posts: 11
|
1996 Carryall Throttle/Brake Problem Post Lift
Evening BGW! Purchased a Jakes 6" Spindle lift for my '96 Carryall 1 and installed this past weekend. Did the whole thing with hand tools and was a PITA!
To get the back buttoned up, had to drop the whole motor/axle unit quite a bit down (to the extent a ground from the alternator snapped). Got that fixed and the back buttoned up today, but went to crank the cart and it started at 1/2 throttle if not more. Brakes are also very loose. Didn't touch anything on the throttle and brake lines other than the little brake wire holder which was reinstalled. I'm 100% stumped and hoping for some guidance before I break down and have a shop look at it. Any help would be much appreciated. Bryant |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-14-2017, 10:10 AM | #2 |
Not Yet Wild
Join Date: Jun 2017
Posts: 11
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
bump, anyone have any ideas? Desperate here.
Thanks! |
08-14-2017, 08:58 PM | #3 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
So this is way beyond my expertise...
But inside the electrical box right beside air breather.. Their is a half moon lever that hits the switch, I think that switch is what starts the cart when you push the pedal.... That moon has notches, I think that's where you can adjust the throttle. Sent from my Nexus 6P using Tapatalk |
08-14-2017, 09:02 PM | #4 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
Also read the speed up your cart sticky... It talks about lengthening the gas pedal rod, and brake pedal..
That may be what you need more to adjust your cart...... Again not my expertise! Just a couple ideas to Tinker around with until expert comments..... Good luck Sent from my Nexus 6P using Tapatalk |
08-15-2017, 10:13 AM | #5 |
Not Yet Wild
Join Date: Jun 2017
Posts: 11
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
I'll check it out. Thanks!!
|
08-23-2017, 11:52 AM | #6 |
Not Yet Wild
Join Date: Jun 2017
Posts: 11
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
For anyone else that might run into this, I was able to adjust the tension back to stock thresholds.
|
09-17-2017, 02:10 PM | #7 |
Not Yet Wild
Join Date: Sep 2017
Posts: 18
|
Re: 1996 Carryall Throttle/Brake Problem Post Lift
Any photos of this thing lifted? Must look killer
|
|
|
Similar Threads | ||||
Thread | Forum | |||
club car precedent lift kit/brake cable problem | Electric Club Car | |||
I adjusted the throttle now the Parking brake locks as the brake pedal is pressed | Electric Club Car | |||
1996 cc carryall | Gas Club Car | |||
Ezgo Charger conversion Post 1996 to Pre 1996 | Electric EZGO | |||
throttle problem,new controller,throttle works backwards | Electric EZGO |