![]() |
![]() |
#1 |
Not Yet Wild
Join Date: Apr 2012
Posts: 6
|
![]() I have a 1995 gas ez go, put a new solenoid in it and now it will not shut off after starting it, not even the key will shut it off, i have to disconnect the leads to the battery..any help would be appreciated.
|
![]() |
![]() |
![]() |
|
![]() __________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
![]() |
#2 |
Happy Carting
![]() ![]() Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
![]() It sounds like you might have a bad micro switch.
It might be the motor kill micro in the little black box at the end of the accelerator cable. Best if you could check a diagram to see where it's located, unless somebody chimes in who knows for sure. |
![]() |
![]() |
![]() |
#3 |
I Refuse To Get Stuck!!!
![]() Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
![]() Could be a defective solenoid too.Did you use a replacement unit,or was it from an auto-parts store?If you use an automotive-replacement,you need to get a Continuous-Duty Solenoid,either for a Snow-Plow,or a Lift-Gate/Hydraulic-Dump.Starter Solenoids are meant for a quick use,not non-stop like carts run,They fry quickly!Hope this helps.
![]() |
![]() |
![]() |
![]() |
#4 |
Happy Carting
![]() ![]() Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
![]() YEp, we see that often enough....
|
![]() |
![]() |
![]() |
#5 |
I Refuse To Get Stuck!!!
![]() Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
![]() I work for a Fisher Plow Dealer,So I use the Fisher Solenoids,Work great,and they are one of the most common solenoids used by most aftermarkets for dumps,lift-gates,etc..Its a round,Tower-Style made by Trombetta.Mine has been in there for 2 hard years,and still going strong,The first one was in there 2-years and it was a used take-out from a plow-swap(no idea how old it was).
![]() |
![]() |
![]() |
![]() |
#6 |
Not Yet Wild
Join Date: Apr 2012
Posts: 6
|
![]() here is the one i just put in it.....EZGO Golf Cart part 14-v solenoid for gas vehicles, oem white rodgers
This is the one i put in it before the one above...... 12v solenoid for you're 1979 and up E-Z-GO gas golf cart. Both are doing the same thing. It will start but not shut off. I can tap on the solenoid with a screw driver and it shuts it down. Thats all I got. Dont know what else to do. |
![]() |
![]() |
![]() |
#7 |
Not Yet Wild
Join Date: Apr 2012
Posts: 6
|
![]() I cannot find the micro switch yet and cannot find a diagram online that is free. Still looking.
|
![]() |
![]() |
![]() |
#8 |
Not Yet Wild
Join Date: Apr 2012
Posts: 6
|
![]() Thanks for All the advice also.
|
![]() |
![]() |
![]() |
#9 |
......................
![]() Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
![]() |
![]() |
![]() |
![]() |
#10 |
I Refuse To Get Stuck!!!
![]() Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
![]() If you tap the Solenoid and it drops out,replace the solenoid,its' defective(the coil is binding-up internally).
![]() |
![]() |
![]() |
![]() |
|
|
![]() |
||||
Thread | Forum | |||
Solenoid Replacement | Electric Club Car | |||
'94 EZ Go Tie Rod End Replacement | Electric EZGO | |||
Solenoid Replacement Problem | Electric EZGO | |||
Solenoid repair or replacement | Electric Club Car | |||
Top End Replacement | Gas EZGO |