|
|
|||||||
| Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
09-20-2008, 06:30 AM
|
#1 |
|
Not Yet Wild
Join Date: Sep 2008
Location: In the Magnolia State
Posts: 47
|
Back together and running with a new problem!
Got the old G2 back together. The poor idling and rattling noise are both gone. Now it has a tough time getting started. I have to pump the peddle with the engine spinning. When it hits she starts. "the beast" as I call her has really challenged my nerves. Also when it idles it cuts on an off. I can hear a clicking. Sounds like a rev limiter or something. Not smooth like the governor and not missing. Any thoughts!
 Thanks, JW "the shade tree mechanic" stressing on "the beast" Project G2 |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
09-20-2008, 12:14 PM
|
#2 |
|
Not Yet Wild
Join Date: Sep 2008
Location: In the Magnolia State
Posts: 47
|
Re: Back together and running with a new problem!
Cutting on and off again at low idle. Where would be the first place to start looking on the ignition side of things?
|
|
|
|
|
09-21-2008, 01:57 PM
|
#3 |
|
Not Yet Wild
Join Date: Sep 2008
Location: In the Magnolia State
Posts: 47
|
Re: Back together and running with a new problem!
I hope that this post helps someone in the same situation that I have been in. Pulled the carb back down and found the pilot port stopped up. Used a very small torch tip cleaner and it starts and idles pretty good. I still have a switch somewhere cutting on and off. I am beginning to believe that it may be the stop switch. I am going to pursue it this afternoon.
|
|
|
|
|
09-21-2008, 06:57 PM
|
#4 |
|
Not Yet Wild
Join Date: Sep 2008
Location: In the Magnolia State
Posts: 47
|
Re: My last post on this thread.:occasion5:
Got it!!!!! She is finally running like a top. Final problem was a throttle cable adjustment at the gas pedal. Move on to the suspension, and drive train.
  |
|
|
|
|
09-21-2008, 07:01 PM
|
#5 |
|
Admin/Moderator
 Join Date: Dec 2006
Location: Ohio
Posts: 18,052
|
Re: Back together and running with a new problem!
Great!! Glad to hear it.
|
|
Ron
 PLEASE VISIT Our Sponsors * BGW GEAR The Store The G2 Project * Swing Arm Drop & Repair * Geep1 Project |
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Im Back and Have A New Toy | Lifted Golf Carts | |||
| Back end | Electric Club Car | |||
| 1985 g1 running problem | Gas Yamaha | |||
Linear Mode
