|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
06-15-2018, 03:21 PM
|
#1 |
|
Getting Wild
Join Date: Nov 2015
Posts: 77
|
2011 Electric Precedent does nothing
I have a electric 2011 Precedent That does nothing.
Battery pack OK. Batteries charge just fine. When in reverse no buzzer. Solenoid does not close. Have tested Solenoid by supplying 48vdc to coil and it closes. Best I can tell by troubleshooting guide MCOR is OK. Is there a way to bypass the OBC and is there a way to test the controller. Any help would be appreciated. Thank you, Ken |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
06-15-2018, 03:46 PM
|
#2 |
|
Gone Wild
 Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2011 Electric Precedent does nothing
A bad OBC lockout circuit will do that.
Disconnect the 6-pin connector from the OBC. Using a large paper clip or a stiff wire jump the White and the Blue wires on the 6-pin connector that is in the cart harness side. Use some electrical tape on any exposed wire to prevent a short. Test drive the cart. |
|
|
|
|
06-26-2018, 11:06 AM
|
#3 |
|
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2011 Electric Precedent does nothing
Still does nothing. I would assume then the OBC is defective.
|
|
|
|
|
06-26-2018, 11:28 AM
|
#4 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2011 Electric Precedent does nothing
Nope, that test just eliminated the OBC lockout being the cause of the problem.
Check the 15 amp fuse in the harness fuse holder near the controller 16-pin connector. |
|
|
|
|
06-26-2018, 02:08 PM
|
#5 |
|
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2011 Electric Precedent does nothing
Fuse OK.
|
|
|
|
|
06-26-2018, 02:52 PM
|
#6 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2011 Electric Precedent does nothing
Do You get any voltage at the Key Switch when the Tow/Run switch is on Run?
|
|
|
|
|
06-29-2018, 03:30 PM
|
#7 |
|
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2011 Electric Precedent does nothing
Yes.
Re-checked the Forward/Reverse switch and it is ok. Re-checked the MCOR and it is ok. Works in another cart just fine. Stumped.. |
|
|
|
|
06-30-2018, 12:23 PM
|
#8 |
|
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2011 Electric Precedent does nothing
Jack the rear wheels up off of the ground and remove the controller access cover. Unplug the 16 pin connector from the controller.
At this point you need to check for every signal coming into the controller. Put your meter on 200V DC and place the negative probe on the main negative battery terminal. With key switch on, F&R switch in forward, and tow/run switch in run, check for power on the grey wire, tan wire, and brown wire. You should have power on all three of these wires. If you don't, let us know which one. |
|
|
|
|
07-03-2018, 01:51 PM
|
#9 |
|
Getting Wild
Join Date: Nov 2015
Posts: 77
|
Re: 2011 Electric Precedent does nothing
Have full battery voltage at all three wires.
|
|
|
|
|
07-03-2018, 04:41 PM
|
#10 |
|
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2011 Electric Precedent does nothing
Check for power on pin 6, the solid green wire, with the key on, tow/run switch in run, f&r switch in forward, and accelerator pedal down.
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Axle from a 2011 Precedent electric | Golf Carts and Parts | |||
| 2011 Club Car Precedent - Electric | Golf Carts and Parts | |||
| 2011 Precedent electric Club Car Heditates | Electric Club Car | |||
| 2011 Electric RXV | Electric EZGO | |||
| 2009-2011 Electric Precedent Maintenance and Service Manual | Electric Club Car | |||
Linear Mode
