|
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
04-07-2020, 08:56 PM | #1 |
Getting Wild
Join Date: Apr 2020
Location: Wisconsin
Posts: 82
|
Top speed surges for a bit
Just got my 48v cart out of storage and going through everything and found as you go on an initial drive and open it up it tends to hesitate and surge trying to reach top end, no surging at low or mid throttle just when it’s to the wood. But 30 seconds or so into the ride it seams fine after several attempts to reach top speed. It’s a 2011 6 8volt system and battery’s are good. It kinda acts like it needs to warm up.....
Thanks for the help ! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-08-2020, 01:05 PM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Top speed surges for a bit
Is the tach sensor on the motor plugged in?
|
04-08-2020, 07:41 PM | #3 |
Getting Wild
Join Date: Apr 2020
Location: Wisconsin
Posts: 82
|
Re: Top speed surges for a bit
If the sensor on the passenger side of the motor is the tach sensor than yes it is plugged in. It seemed like it the plug wouldn’t click, so I blew it out and added a little dielectric grease and plugged it back in and got the plug to click. Checked the leads on the motor and the battery. Reached up to the module that is way up by the seat area and all seamed ok there as well.
|
04-08-2020, 09:39 PM | #4 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Top speed surges for a bit
Stock motor & controller? The orange lifted cart?
|
04-09-2020, 05:20 AM | #5 |
Getting Wild
Join Date: Apr 2020
Location: Wisconsin
Posts: 82
|
Re: Top speed surges for a bit
Correct, and has a 20mph speed chip in it.
Tire size is 22x10-12 |
04-09-2020, 07:41 AM | #6 |
Getting Wild
Join Date: Apr 2020
Location: Wisconsin
Posts: 82
|
Re: Top speed surges for a bit
I checked this morning and tow switch on RUN when u push the Cart clicks on when it’s pushed and clicks off when it stops
|
04-09-2020, 10:41 AM | #7 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Top speed surges for a bit
Pull & inspect motor, I bet its brushes are about done.
|
04-09-2020, 01:09 PM | #8 |
Getting Wild
Join Date: Apr 2020
Location: Wisconsin
Posts: 82
|
Re: Top speed surges for a bit
Oh boy, I’m hoping those are serviceable, thanks for the info.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2003 EZ-Go Gas Surges at Top Speed | Gas EZGO | |||
PH1109 Surges/jerkey at Slow speed | Electric Club Car | |||
G22 speed fluctuates (Surges) | Electric Yamaha | |||
EZGO PDS cart lost speed and surges | Electric EZGO | |||
2008 Drive "surges' at low speed | Electric Yamaha |