|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-25-2017, 06:08 AM | #11 |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-25-2017, 06:31 AM | #12 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,931
|
Re: She cranks with verified fuel and spark, but no go?
Without ACR - 156 psi
With ACR - 71 psi But, will be less depending on age and wear of the engine. There are 2 ways...
021 (3).JPG 035.JPG |
05-25-2017, 06:41 AM | #13 |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
I probably have ACR then... My cart is a 2008, keyed ignition, with Kawasaki. I haven't found the yellow sticker anywhere, but I guess it could have been removed at some point. It currently has 2004 hours on it.
I would figure that either way 35 PSI isn't enough? |
05-25-2017, 06:44 AM | #14 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,931
|
Re: She cranks with verified fuel and spark, but no go?
When testing the compression... did you hold the GO pedal to the floor while cranking it?
If not... you'll need to! |
05-25-2017, 06:47 AM | #15 | |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
Quote:
I think the pedal was to the floor, but I did have my 8 year old son pushing it while I was reading. I will try again this evening and make sure it is all the way down when testing. |
|
05-25-2017, 06:18 PM | #16 |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
I found the "w/o ACR" sticker Ran the compression test again and the range is between 25-35 PSI. Looks like I'm in trouble...
|
05-26-2017, 08:38 AM | #17 |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
Any suggestions on where to go from here? Should I go to a small engine shop and have top end rebuilt or just swap out with new engine? I'm not sure of expected cost to rebuild, but I did see that Vegas Carts has their 460cc for $600 and also found an Ironton 420cc engine at Northern Tool for $250. I'm just looking for any input or experience that some of you can offer. Thanks.
|
05-26-2017, 09:28 AM | #18 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: She cranks with verified fuel and spark, but no go?
Slow down speed racer have you checked valve lash yet? Low compression can by cause by valve lash to tight not allowing valve to close all the way
|
05-26-2017, 04:24 PM | #19 |
Not Yet Wild
Join Date: Sep 2007
Location: South Georgia
Posts: 55
|
Re: She cranks with verified fuel and spark, but no go?
Is the spark plug firing? https://www.youtube.com/watch?v=mUOmsGiirTU
|
05-26-2017, 04:52 PM | #20 |
Not Yet Wild
Join Date: May 2017
Location: Urbana, OH
Posts: 13
|
Re: She cranks with verified fuel and spark, but no go?
Update: I pulled the valve cover and both valves are all the way out. I'm getting blow by. If I press the valves down by hand and try to turn it over it wants to start. I'm thinking I may have a bad cam or something along that line...
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Have Fuel Have Spark What next? | Gas EZGO | |||
Has spark & fuel but won't start | Gas Club Car | |||
G22 Starting Issue - Cranks and Cranks for Initial Start | Gas Yamaha | |||
new member, need thoughts verified or changed | Electric Club Car | |||
getting fuel, getting spark, cranks with starter fluid in carb | Gas EZGO |