|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-19-2017, 12:24 PM | #1 |
Not Yet Wild
Join Date: Sep 2017
Location: Northwest Florida
Posts: 17
|
1999 ezgo txt gas not charging
Just purchased used cart. Noticed battery not charging. Read most problem solving initiatives on the web. Found wiring around voltage reg., solenoid & ignitor a mess. Ground connections corroded and questionable. Rewired this entire section fwd of battery using schematic found on internet. Replaced voltage regulator. Replaced brushes in starter/gen. Cleaned and improved all electrical connections. System is still not charging. How do I test charging portion of starter/gen.? Any ideas what to do next?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-19-2017, 03:52 PM | #2 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 1999 ezgo txt gas not charging
Unhoom green wire coming out of starter generator and ground it to battery put a meter on battery and with cart in nuetral rev motor up should read around d 16-17 volts at the battery if it does then it's likely a faulty VR if it doesnt than it's starter generator issue I know you said you put new VR on but some people on here have got bad aftermarket ones right out of the box
|
09-20-2017, 08:45 AM | #3 |
Not Yet Wild
Join Date: Sep 2017
Location: Northwest Florida
Posts: 17
|
Re: 1999 ezgo txt gas not charging
Thank you for your reply. Point of clarification. Do I ground the green wire or the terminal I removed it from on the gen? I think I've read to ground one or the other.
|
09-20-2017, 01:07 PM | #4 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 1999 ezgo txt gas not charging
Ground the green wire not the terminal
|
09-21-2017, 08:31 AM | #5 |
Not Yet Wild
Join Date: Sep 2017
Location: Northwest Florida
Posts: 17
|
Re: 1999 ezgo txt gas not charging
Thank you again. Removed and grounded the green wire. I saw no voltage change from a steady 12vdc at the battery. I see that I need to replace or have the motor/gen rebuilt.
|
09-21-2017, 12:41 PM | #6 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 1999 ezgo txt gas not charging
Check all connections and if all are clean and tight this test points towards a new or rebuild starter generator I believe someone on her had similar problem and something was shorted internal but I can't find the thread
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1999 EZGO TXT versus 2012 EZGO TXT PDS | Drivers Clubs | |||
1999 DCS will not move after charging | Electric EZGO | |||
1999 DS Charging / OBC Issues | Electric Club Car | |||
1999 Club Car not charging | Electric Club Car | |||
melex 1999 model 625e charging problem | Electric golf carts |