|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-07-2010, 08:30 AM | #1 |
Not Yet Wild
Join Date: Dec 2009
Location: Hemet, CA
Posts: 11
|
Charger shuts off - Need help
I have a 2007 CC Precedent with (4) 12 volt batteries. I removed the batteries and cleaned the tub of old residue cleaned all the terminals and terminal ends. When I replaced the batteries and wiring the buggy ran fine but wouldn't charge. When I plug in the charger it comes on, hums loudly, the amperage indicator never moves and within 15 seconds the breaker on the front of the charger pops out. Any suggestions?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-07-2010, 09:16 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: Charger shuts off - Need help
If the charger worked fine before you removed the batteries then the problem is with the install. Check the voltage at the charge receptacle to see what the charger sees. I'm thinking you may not have reconnected the charge wires correctly or burnt a fuse...
|
11-07-2010, 10:36 AM | #3 |
Not Yet Wild
Join Date: Dec 2009
Location: Hemet, CA
Posts: 11
|
Re: Charger shuts off - Need help
Thanks for the reply. Here's some more info. The voltage @ each battery is between 12.1 and 12.2. The total system voltage between the positive of the left front battery and the negative of the right front battery (as I'm facing forward) is 49.0v. I found 2 fuses, one in a red line and one in a blue line and they both check out. When I check the voltage @ the charger plug-in I only get 38.8v. I think I have the batteries connected properly but I can't find a diagram of the 4-12v system with 2 batteries on each side. Any help would be greatly appreciated.
|
11-07-2010, 11:29 AM | #4 |
Not Yet Wild
Join Date: Dec 2009
Location: Hemet, CA
Posts: 11
|
Re: Charger shuts off - Need help
More info. When looking at the charging socket the voltage between the 2 bottom holes, labeled + and -, the voltage is 38.8v. When checking from the left bottom, labeled - to the top I get 9.4v. When checking from the right bottom, labeled +, I get 47.9v. Help anyone?
|
11-07-2010, 12:17 PM | #5 |
Not Yet Wild
Join Date: Dec 2009
Location: Hemet, CA
Posts: 11
|
Re: Charger shuts off - Need help
I tried a friends charger and it works fine. Just a coincidence that I removed and reinstalled the batteries at the same time the charger went south. Thanks all for looking.
|
11-11-2010, 05:31 PM | #6 |
Gone Wild
Join Date: Feb 2008
Location: Central Georgia
Posts: 264
|
Re: Charger shuts off - Need help
Sounds like your diodes are gone. You probably can smell the burnt odor if you get close to the charger.
|
11-11-2010, 09:12 PM | #7 |
Gone Wild
Join Date: Jun 2010
Location: East Texas
Posts: 602
|
Re: Charger shuts off - Need help
Sounds like your diode tree (rectifier). It takes 5 mins to replace and is about $18.00. Take the cover off your charger and it is on the back wall. Little square with 4 wires going into it. Mark the wires and pull them off and test the rectifier with a multimeter. The sticky up top with the powerdrive book will walk you through it step by step. If its bad, go by a CC dealer and get one!
|
11-11-2010, 10:30 PM | #8 |
Gone Wild
Join Date: Sep 2009
Location: Forest City N.C.
Posts: 2,660
|
Re: Charger shuts off - Need help
Does the charger click with a metallic sound after you plug it in?
|
11-22-2010, 10:11 AM | #9 |
Not Yet Wild
Join Date: Dec 2009
Location: Hemet, CA
Posts: 11
|
Re: Charger shuts off - Need help
Replaced the rectifier and it works fine. You have to buy the rectifier from a CC dealer and it comes with instructions for install and heat sink paste. Thanks for all the help.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
When lights on radio shuts off? | Gas Yamaha | |||
02' Club Car IQ shuts down while driving? HELP Please!!! | Electric Club Car | |||
Drives algong then shuts down | Gas Club Car | |||
4 cycle shuts down when hot | Gas EZGO | |||
txt goes than shuts down than it goes | Electric EZGO |