06 DS 48v rev Buzzer stays on & NO-GO fwd or reverse

[never2old4this]

Purchased a 2006 Club Car DS 48v in non-running condition. Was told it needed a controller & it would run prefectly......so this is my new learning curve. Hooked car up to charger, it came on, charged & turned off. Then switched car from tow to drive & reverse buzzer came on right away, even with ignition key in off position. I then purchased a new controller..OUCH & did the swap. Switched from tow back to run with fingers crossed & exactly the same situation. Buzzer is on, only way to switch it off is to place vehicle in tow or disconnect batteries. Any ideas ?

[CCFanatic]

Is the FNR toggle switch in Reverse?

EDIT: If you could include the serial number as well, that would be helpful. It should be located on a tag above the GO pedal below the right side glove box

ANOTHER EDIT: Can you hear the solenoid click when you press the GO pedal?

[Stevegrmich]

. . . try info in this thread:

http://www.buggiesgonewild.com/elect...wont-move.html

[never2old4this]

Originally Posted by CCFanatic

Is the FNR toggle switch in Reverse?

EDIT: If you could include the serial number as well, that would be helpful. It should be located on a tag above the GO pedal below the right side glove box

ANOTHER EDIT: Can you hear the solenoid click when you press the GO pedal?

It does not matter what position the switch is in, I even removed the switch and jumped wires, it makes no difference. Pressing GO pedal results in nothing forward, in reverse the car attempted & I guess the best explanation would be it "shuddered" a foot vey slowly & then stopped & nothing when I pressed the pedal again. I will look for the Serial number & post, thanks.

[CCFanatic]

Was the replacement controller new? Do you happen to have the model number of the replacement controller?

[never2old4this]

Originally Posted by CCFanatic

Was the replacement controller new? Do you happen to have the model number of the replacement controller?

New Controller - Curtis PMC - Model # 1510-5201

[never2old4this]

My neighbour has an 02 DS. If he will let me borrow his Cart ,are the parts interchangable to swap back and forth for diagnostics ?

[CCFanatic]

Originally Posted by never2old4this

My neighbour has an 02 DS. If he will let me borrow his Cart ,are the parts interchangable to swap back and forth for diagnostics ?

If you could get serial numbers for both, we could determine that for you

[never2old4this]

Thank you for all the responses. I borrowed my neighbors '02 DS-48v & with his assistance, we swapped his controller into my car - NO Change, still no fwd or rev, buzzer still on. SO thats three controllers with the same result. I convinced him to let me try swapping computers & he reluctantly agreed. EUREKA.......computers swapped, switched car from tow to run & NO buzzing. Turned key on, battery light came on, heard a click, battery light turned off, car works perfectly........So I have to order a replacement computer now.