|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-17-2014, 12:05 PM | #1 |
Gone Wild
Join Date: Jan 2009
Location: North Topsail Beach, NC
Posts: 231
|
#1 battery loses charge
Hey Guys....I have a 94 ezgo medalist that I have been working on...Runs great but lately seems like the batteries don't last as long as they should.
I have gone through and cleaned all the batteries and cable to include cables to the motor. All connections are clean and good. Did a gravity check on the batteries which are about 3 years old and all are fair to good. The cart charges to 39 plus but don't hold the charge long. After a short distance the Number 1 battery is always lower than the others..All will be around 6.2 and the number one battery will be around 5.7ish...I have switched the batteries around several times and its always the number one battery that is lower than the rest. Anyone have any ideas... Thanks Bill |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-17-2014, 12:26 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: #1 battery loses charge
could the charge wires be connected to 5 batteries? Does the #1 battery come up when charged?
Extra draw on #1 like lights? |
12-17-2014, 12:33 PM | #3 |
Gone Wild
Join Date: Jan 2009
Location: North Topsail Beach, NC
Posts: 231
|
Re: #1 battery loses charge
Yea Scotty...when fully charged all batteries are within a point of each other. last total charge was 39.3 which is good for 3 year old batteries...but yes, which ever battery is in number spot charges same as others....I have already replaced the #1 battery cable to the controller and from the controller to the motor.....no difference...
|
12-17-2014, 12:38 PM | #4 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: #1 battery loses charge
There are many ways to number the batteries, which one is #1?
The batteries are connected in series, so they are charged and discharged equally and the differences in each battery voltage should reflect differences in the storage capacity of the batteries themselves, rather than their position. If position-1 has a parasitic drain for some reason, that would explain the battery voltage be position sensitive. Or if position-1 was hotter, or colder, than the rest, that could also explain it. --------- What are the individual battery voltages about 12 hours after the charger shuts off automatically? What are the individual battery voltages about 1/2 hour after the cart has been driven a couple miles? |
12-17-2014, 01:21 PM | #5 |
Gone Wild
Join Date: Jan 2009
Location: North Topsail Beach, NC
Posts: 231
|
Re: #1 battery loses charge
Hey JohnnieB...If its one thing I have learned from you and ScottyB and others of course over the past 5 years is batteries..batteries...batteries...I work on a lot of golf carts in our campground as a hobby more than the money and have learned a great deal from all of you...
My problem has been going on for a couple weeks now...What I am calling the Number 1 battery is the one the one that connects to either the solenoid or the controller (depending on the golf cart). Number 6 being the negative back to the motor... After charging all night (until charger shuts off) I have pack voltage of around 39.2 to 39.3...which I think is great for 3 year old batteries. I also check each battery and ALLsaround 6.50 +-.....After driving for a short distance say 1/2 mile, the pack voltage will drop to around say 36.8 +-. Then checking each battery all with be with in a small range, ie 6.10+-. except for the number one battery with will be well below 6 volts..say around 5.80+-. The same thing happens each time I switch the batteries around..The number 1 battery is always low....I have checked before and after riding and the batteries do not lose a charge just sitting. They will in time equalize but will not drop once that occurs. I have done gravity checks several time on all batteries and it shows good to include the low number one battery... what do you think...could I possible have brushes in the motor shorting out and pulling the number 1 battery down quicker than the pack can equalize. |
12-17-2014, 01:37 PM | #6 |
Gone Wild
Join Date: Oct 2009
Posts: 486
|
Re: #1 battery loses charge
3 year old batteries are old and out of warranty. Time for a replacement. You just happen to have one battery weaker than the other 5.
|
12-17-2014, 02:21 PM | #7 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,170
|
Re: #1 battery loses charge
You have at least one bad battery.
|
12-17-2014, 02:43 PM | #8 |
Gone Wild
Join Date: Jan 2009
Location: North Topsail Beach, NC
Posts: 231
|
Re: #1 battery loses charge
No Sir...don't have a bad battery....That number one battery can be put in other places and its fine...What ever battery that is put in the number one spot looses voltage while running....If batteries are taken care of, keeping water level up, charging properly, terminals clean you should be able to get 5 years if not 6 out of them...
ALL batteries check out fine with meter and gravity check.... |
12-17-2014, 02:52 PM | #9 |
Gone Wild
Join Date: Jan 2009
Location: North Topsail Beach, NC
Posts: 231
|
Re: #1 battery loses charge
Also guys, after that 1/2 mile run dropping a couple volts you would think there would be a hot wire somewhere....but have check all battery and motor wires, everything feels normal...nothing hot...
|
12-17-2014, 03:23 PM | #10 |
Gone Wild
Join Date: Jul 2013
Location: Mid Michigan
Posts: 207
|
Re: #1 battery loses charge
can you post a picture of your battery pack
and somehow mark which is position number 1? maybe we can see something in the wiring that will lead us to some useful ideas and questions. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Battery charge | Electric EZGO | |||
1 New battery, how to charge | Electric EZGO | |||
yamaha cart loses charge | Electric Yamaha | |||
G2 won't charge battery | Gas Yamaha | |||
electric clubcar loses charge and power quickly | Electric Club Car |