lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-15-2020, 07:22 AM   #1
petero
Not Yet Wild
 
Join Date: Nov 2013
Posts: 28
Default ezgo gas new coil

15-7-2020 005.jpgHi all. Thought I would share this .Recently my ignition coil failed. I tested the resistance and could not get a reading on the secondary circuit so the coil was done but I thought that I would check the wiring for continuity anyway so I disconnected the small 4 pin connector that comes from the igniter tested the wiring. All good.
Installed the new ignition coil and got no spark. I asked for help and got great advice from TRIG123. I followed his instructions to the letter and repeated it again but all the readings were in reverse to what I should be getting. I was really stuck after pondering this for quite a while i dawned on me that I hand disconnected the 4 pin connector so I checked I had it properly connected it seemed to be but with everything being in reverse I thought I wonder and I turned the connector round and hay presto everything was good.
I know this sounds confusing but basically the four pin connector comes from the igniter this has the wiring from the pick up coil and the ignition coil. If you have this apart do NOT reconnect it so the wires on both sides corispond. If it is correct you should be getting about 11.5 v on the white and very little on the red with the engine spinning and the white is the only one that will light a test light. the plug should be connected so that the red connects to the white.hope this is not to cofusing.
petero is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
Yamaha jf2 ignitor, coil, pulsar coil for sale Golf Carts and Parts
Ezgo coil 4 stroke Golf Carts and Parts
EZGO Coil Gas EZGO
ezgo with coil near the battery Electric EZGO
89 ezgo ignition coil Golf Carts and Parts


All times are GMT -5. The time now is 10:57 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.