|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
02-05-2011, 01:02 AM | #1 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
Grounding To the frame
Has Anyone heard about not grounding anything to the frame on a Gas Powered golf cart, Have any good work arounds for grounding stuff IE the headlights radio???
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-05-2011, 01:45 AM | #2 |
Gone Wild
Join Date: Aug 2010
Location: Kentucky
Posts: 207
|
Re: Grounding To the frame
You can ground directly to the battery.
I can't speak for all gas golf carts, but the G1 is grounded to the frame. You can add additional electronics and ground them to the frame, but you run the risk of overloading the ground and constantly pop fuses. |
02-05-2011, 07:35 AM | #3 |
Gone Wild
Join Date: Dec 2009
Location: Ohio
Posts: 1,143
|
Re: Grounding To the frame
I wouldn't ground anything to the frame...take everything to the batt. or put a grounding block in ,you can get at autozone..
|
02-05-2011, 08:18 AM | #4 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: Grounding To the frame
I don't know on the Yamaha but the on EZGO the battery negative bolts directly to the frame as does the engine ground. If you followed your negative and it is bolted to the frame then the frame is grounded so you can pick up your grounds from the frame. I do know that electric carts have a floating frame so all grounds must go directly to the battery negative.
|
02-05-2011, 08:22 AM | #5 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Grounding To the frame
Bud, I put a couple 12 gage short 5" pig tails on the starter ground lug. (on the starter end cap, where the large ground cable from the battery, bolts to.) I am able to ground any additional accessories from there.
I can probably get you a picture later in the day (daylight) if you like. |
02-05-2011, 08:40 AM | #6 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: Grounding To the frame
There is nothing wrong with frame-grounding as long as your connections are clean(grind/sand off paint/rust).The Ez-Gos' also frame-ground the wiring to the rail.Granted stuff like radios,gps,high-power lites work better with a direct ground sometimes(depends on interference with other electronics and amp-draw).I would recommend increasing the ground-cable size by 1-size,if you have a lot of "toys" on your cart,to handle the extra amp-draw capacity.Always coat the ground-connections with a electrical-sealer to protect from corrosion.I work on Heavy-Trucks,and International grounds their batteries to the frame(sometimes 8' from the engine)and grounds the engine,cab,etc..also to the frame(not to one point,they run a short wire from engine to frame-rail,batts to frame-rail)These are fully electronic-controlled and it works,so use your own judgement.Hope this helps.
|
02-05-2011, 08:45 AM | #7 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Grounding To the frame
Pach, not on a Yamaha. You can blow the TCI on a G8. Best to ground to the battery, sorry this is what I ment to say.
|
02-05-2011, 08:53 AM | #8 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: Grounding To the frame
Every cart is different,But..I did say frame grounding is fine,so take it for what its worth.
|
02-05-2011, 11:35 AM | #9 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: Grounding To the frame
All grounds end up at the frame anyway
|
02-05-2011, 01:56 PM | #10 |
Admin
Join Date: Dec 2006
Location: TN
Posts: 101,868
|
Re: Grounding To the frame
If you ground to the frame of a Yamaha, it will blow the main fuse every time. Ground straight to the neg. post on the battery.
DO NOT GROUND TO THE FRAME ON A YAMAHA....... |
|
|
Tags |
yamaha, yamaha g! |
|
|
Similar Threads | ||||
Thread | Forum | |||
Coil Grounding on 88 EZGO | Gas EZGO | |||
1982 G1 grounding issue | Gas Yamaha | |||
Grounding Problem | Electric Club Car | |||
grounding battery pack? | Electric EZGO |