|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-30-2022, 04:35 PM | #1 |
Not Yet Wild
Join Date: Oct 2020
Location: Florida
Posts: 13
|
2015 Carryall 550 efi not starting
My pedal start Carryall with the Subaru engine turns over but does not start. I am getting NO CODES from the oil light. The fuel pump is not pressurizing when I turn the key on.
Following the troubleshooting guide: 1. I have confirmed that I have voltage to the pump immediately after the key is turned on for a few seconds. 2. Testing the fuel pump module for resistance I am getting 8.1 ohms. The book says the reading should be 2-5 ohms. If it were lower than 2, the module is shorted and shot, but it doesn't say what it means when the reading is above the range. In most pumps it would mean there is an open/poor connection and also probably shot. I'm suspecting that I will need to replace the fuel module. Appreciate any advice on this. Thank you! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-02-2022, 01:55 PM | #2 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 2015 Carryall 550 efi not starting
May need a new pump. Is there any voltage on the ground side of the pump?
Try giving it a tap it two with a screwdriver handle right after turning the Key on and see if it starts doing anything. |
07-07-2022, 01:58 PM | #3 |
Not Yet Wild
Join Date: Oct 2020
Location: Florida
Posts: 13
|
Re: 2015 Carryall 550 efi not starting
Update: I reconfirmed that I have spark and I have voltage to the pump. I pulled the fuel module and retested for resistance and got zero. That's a good BINGO! I also discovered that the line was broken. Not sure its related but I'm sure it wasn't helping. In any event, I have a new module on order and that should get me up and running.
Fuel Pump.jpg Last edited by Blueeyedme; 07-07-2022 at 02:06 PM.. Reason: Added photo |
07-29-2022, 03:10 PM | #4 |
Not Yet Wild
Join Date: Oct 2020
Location: Florida
Posts: 13
|
Re: 2015 Carryall 550 efi not starting
Final update: Ordered a new fuel pump module (105043401) from China. $160 shipped and arrived in 16 days. Looks exactly like the assembly I pulled and fit perfectly. Back up and running.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2015 Club Car Carryall 300 | Gas Club Car | |||
2015 club car carryall engine swap | Gas Club Car | |||
2015 club car carryall | Gas Club Car |