|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-23-2018, 09:33 PM | #11 |
Gone Wild
Join Date: Dec 2016
Location: Kingsland, Georgia
Posts: 1,825
|
Re: DS power drive slow jerky and throttle hesitates
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-25-2018, 10:26 AM | #12 |
Not Yet Wild
Join Date: Mar 2018
Location: Illinois
Posts: 12
|
Re: DS power drive slow jerky and throttle hesitates
pulled the motor, brushes don't look bad, no dark or blk spot as if sparking or anything on the armature that I would call irregular.
I checked all connections again, cleaned up the armature where the brushes run, put back together and same result. could a motor controller give this jerky intermediate result? this cart is in great condition if it would only run |
03-25-2018, 11:11 AM | #13 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: DS power drive slow jerky and throttle hesitates
Did you do what I asked in post #9? ("it wasn't jerky until the MCOR was replaced")
|
03-25-2018, 12:53 PM | #14 |
Not Yet Wild
Join Date: Mar 2018
Location: Illinois
Posts: 12
|
Re: DS power drive slow jerky and throttle hesitates
No I have not reached out to David as of yet, I wanted to check the brushes on the motor and see what they looked like, which turned out to look ok.
I found two wires crossed on the motor from the first reassembly the S1 and A1 after checking a diagram the cart is acting better but still not enough power to operate right. Acceleration peddle has to be push most of the way doown to have anything happen, and then if at all. Still lost. I did install a MCOR junky Chinese switch this might be my issue just not sure. |
03-25-2018, 12:59 PM | #15 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: DS power drive slow jerky and throttle hesitates
Based on everything you checked and the timing of it, I really think that is your problem.
|
03-25-2018, 01:14 PM | #16 |
Not Yet Wild
Join Date: Mar 2018
Location: Illinois
Posts: 12
|
Re: DS power drive slow jerky and throttle hesitates
Sent David a email, hope to hear from him soon.
|
03-25-2018, 02:20 PM | #17 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: DS power drive slow jerky and throttle hesitates
If not, call him tomorrow after 9 a.m. It will be best to "speak" with him about your dilemma so he can walk you through some checks.
|
03-25-2018, 02:21 PM | #18 |
Not Yet Wild
Join Date: Mar 2018
Location: Illinois
Posts: 12
|
Re: DS power drive slow jerky and throttle hesitates
Ok thanks
|
03-26-2018, 09:32 PM | #19 |
Not Yet Wild
Join Date: Mar 2018
Location: Illinois
Posts: 12
|
Re: DS power drive slow jerky and throttle hesitates
UPDATE:
I spoke to David at Revolution golf carts great guy we went through testing things while he was on the phone seems to came down to the controller. I should have it by the end of the week fingers crossed this corrects it. I will update this post once I get the controller installed. |
03-27-2018, 06:59 AM | #20 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: DS power drive slow jerky and throttle hesitates
He is top notch all the way and has the experience to guide you through the correct avenues.... Glad you called him
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Jerry K | Electric EZGO | |||
ez-go PDS drive system intermittent slow drive | Electric EZGO | |||
Jerry riggin windshield help? | Design Center |