|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
06-20-2012, 12:36 PM | #1 |
Not Yet Wild
Join Date: Feb 2012
Posts: 3
|
G-16 sputter until wide open
So ive had this g16 for a few months now and havent had one issue aside from a near roll.. :)
i ditched the governor and did the cable straight to the carb, followed what directions i could find regarding some slack, extra spring and what not. The car ran killer for about 2 months, and i ran it hard, several days out of every week. Lately however, it will not "cruise". it wont backfire, die, or just not start, it is very responsive going up to max speed, but you cant hold the throttle without it jerking back and forth. I apologize if this was covered, i searched and could only find jerking issues involving back fires, dying, or with governor still attached |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-20-2012, 01:39 PM | #2 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: G-16 sputter until wide open
If its at wide open it could be the rev limiter.
|
06-20-2012, 03:48 PM | #3 |
Not Yet Wild
Join Date: Feb 2012
Posts: 3
|
Re: G-16 sputter until wide open
sorry, that was kind of confusing. What i meant was; the cart wont cruise at 1/4, 1/2, 3/4 throttle or any place in between without sputtering.
Wide open, it runs fine |
06-24-2012, 05:57 PM | #4 |
Not Yet Wild
Join Date: Feb 2012
Posts: 3
|
Re: G-16 sputter until wide open
no help on the subject?
|
06-26-2012, 07:10 AM | #5 |
Gone Wild
Join Date: Sep 2010
Location: Erie, Pennsylvania
Posts: 989
|
Re: G-16 sputter until wide open
Not 100% sure here, but I think the "pilot" jet in the carb. is "in play" during low and mid throttle operation. Maybe your problems are in this adjustment. I would try adjusting it in 1/4 turn and try it, then out 1/4 turn out (from original setting) and try it again to see what happens. If no change, put it back where it was. Good luck - RAY
|
|
|
Similar Threads | ||||
Thread | Forum | |||
car keeps cutting out when wide open | Gas Club Car | |||
how long can i go wide open? | Gas Club Car | |||
Wide Open Or Stop!! | Electric Yamaha | |||
Wide Open or cruising slow? | Electric Club Car | |||
it goes to wide open you can not take off slow | Extreme DC! |