|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
09-24-2022, 11:41 AM
|
#1 |
|
Not Yet Wild
Join Date: Jul 2022
Location: AL
Posts: 14
|
Club Car grey fused charging receptacle wire
I recently swapped to lithium (Eco Battery) and changed charging receptacle for onboard charger.
What are y’all doing with the grey fused wire connected to OBC? Would really like to use the feature to not allow the cart to move while plugged in. I am assuming it’s more complicated than just getting it some power when plugged in since Eco Battery did not utilize it. |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
09-24-2022, 11:52 AM
|
#2 |
|
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Club Car grey fused charging receptacle wire
The grey wire triggers the relay in the charger and really doesn’t have anything to do with the interlock.
The interlock can be used, but you will need a 120vAC relay to interrupt the interlock wire for the controller when the charger is plugged in, and your charger will need to be mounted on-board. |
|
|
|
|
09-26-2022, 01:49 PM
|
#3 |
|
Not Yet Wild
Join Date: Jul 2022
Location: AL
Posts: 14
|
Re: Club Car grey fused charging receptacle wire
Ok thanks . I found the sticky detailing what I should do. Just need to figure out how/if I can do it with the eco battery charger
|
|
|
|
|
09-26-2022, 03:38 PM
|
#4 |
|
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,165
|
Re: Club Car grey fused charging receptacle wire
You could use an AC relay that senses the 115V power to trigger the interlock circuit. I agree that the interlock is a good idea but I don't have one on either of my carts. The charging cord runs right where I would be getting in the cart so I am confident that I wouldn't drive it with the cord plugged in. Same for my wife.
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Ezgo 48v charger receptacle grey wire | Electric EZGO | |||
| RoyPow Onboard Charger - Charging Receptacle Blue Wire? | Lithium EZGO | |||
| Wire between charging receptacle and first battery | Electric EZGO | |||
| What is the 3rd wire on the back of my charging receptacle for? | Electric EZGO | |||
| RXV female receptacle grey wire | Electric EZGO | |||
Linear Mode
