|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-21-2019, 11:45 PM | #1 |
Not Yet Wild
Join Date: Oct 2018
Location: St Louis
Posts: 14
|
Mocor cuts out passed 3/4 throttle
I have a 2004 club car DS and I recently put a speed sensor on it because it was doing over regeneration after I did that it would not go past three-quarter throttle on the pedal or the solenoid would kick out and if you let up all the way on the pedal push it back down it’ll go again until you get past three-quarter and it shuts off I’ve had three different mocor’s on it and they all do the same thing. A friend said a solenoid may be weak but even under no load with it jacked up it cuts out at three-quarter. the controller is been replaced on it with the factory one cables are new and the batteries are less than a year old any advice? Someone else said said brushes in the motor may be bad
Sent from my iPhone using Tapatalk |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-22-2019, 05:42 PM | #2 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Mocor cuts out passed 3/4 throttle
Need to check the battery pack voltage at the solenoid while its driving and see how low the pack voltage is dropping. Sounds like a bad battery or poor cable connection.
|
11-22-2019, 05:48 PM | #3 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: Mocor cuts out passed 3/4 throttle
FT, could the MCOR be out of whack and it's throwing the controller into shutdown mode?
|
11-22-2019, 06:12 PM | #4 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Mocor cuts out passed 3/4 throttle
Possible? Maybe if its three chinese MCORs from BU or Ebay.
Checking voltage is free, and easy, and step 1 no matter what the problem is. Bad connection, bad voltage, cart don't work right. Takes all of 20 seconds to check and make sure that's not the problem, before blaming other parts or spending money swapping potentially good parts for cheapo reverse engineered aftermarket part. |
11-22-2019, 06:24 PM | #5 | |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: Mocor cuts out passed 3/4 throttle
Quote:
|
|
11-23-2019, 09:19 AM | #6 |
Not Yet Wild
Join Date: Oct 2018
Location: St Louis
Posts: 14
|
Re: Mocor cuts out passed 3/4 throttle
Absolutely I will check the voltage at rest and under a load. The oem mocor and both the Chinese ones do the same thing
Sent from my iPhone using Tapatalk |
11-23-2019, 10:35 AM | #7 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Mocor cuts out passed 3/4 throttle
What is the model number of the replacement controller?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Throttle cuts out while driving | Electric Club Car | |||
2005 TXT cuts out at 3/4 throttle | Electric EZGO | |||
93 ez go cuts out at near full throttle | Electric EZGO | |||
G16 Cuts Out If Not 3/4 Or Full Throttle | Gas Yamaha | |||
91 Ez GO CUTS OUT AT 3/4 THROTTLE | Electric EZGO |