|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-22-2015, 10:58 AM | #1 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
1991 ds cranks but wont start
I have spark,compression and fuel but all it does is sputter and occasionally fires. I need ideas, Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-22-2015, 11:19 AM | #2 |
Photoshop Guy
Join Date: Aug 2012
Location: Canal Fulton, OH
Posts: 3,845
|
Re: 1991 ds cranks but wont start
Another member with a '91 Club Car having the same issue. Check in here. We're thinking he may have an ignition coil issue:
http://www.buggiesgonewild.com/gas-c...-starting.html |
04-22-2015, 11:22 AM | #3 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
Re: 1991 ds cranks but wont start
I read that post before I started this one. I have good spark all the time though. Its blowing fuel out of the intake side of the carb. I can shut the fuel off and it still does it.
|
04-22-2015, 11:26 AM | #4 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
Re: 1991 ds cranks but wont start
I did ground the plug and have visible spark. Is it possible its a weak spark? 1.99 for a new plug I think I'm going to try it first.
|
04-22-2015, 01:28 PM | #5 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
Re: 1991 ds cranks but wont start
Ok I changed the plug and still no better. Its blowing fuel out the intake side of the carb and starts and dies only when i choke the carb with my hand.
|
04-22-2015, 01:37 PM | #6 |
Gone Wild
Join Date: Mar 2012
Location: CENTRAL PENNSYLVANIA
Posts: 1,466
|
Re: 1991 ds cranks but wont start
ok dirty carb or stuck valve , most likely dirty carb but first take a can of starting fluid and give it a shot and see if it fires up for a few seconds , if it does then you need to pull the carb and clean it up , also how old is the gas you are trying to fire , i would bet you have water buildup in the carb due to the ethanol in the gas absorbing water , that will cause this problem and i be you find water in the bowl or at least the brown goo. clean the carb and change the gas and filters and you should be good to go
|
04-22-2015, 02:32 PM | #7 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
Re: 1991 ds cranks but wont start
I just took the carb apart and it was pretty clean. I used a half can of carb clean and took it completely apart. Back together with fresh fuel and new filters. Still chugging and sputtering and spitting fuel out of the intake side of the carb. I'n stumped unless I have a stuck valve?
|
04-22-2015, 06:15 PM | #8 |
Gone Wild
Join Date: Mar 2012
Location: CENTRAL PENNSYLVANIA
Posts: 1,466
|
Re: 1991 ds cranks but wont start
did you run torch tip cleaners through the ports and make sure they are clear and what was the age of the gas you put in , more than three weeks old and its worthless
|
04-22-2015, 08:28 PM | #9 |
Not Yet Wild
Join Date: Mar 2014
Location: Rantoul,IL
Posts: 74
|
Re: 1991 ds cranks but wont start
After spending all day trying this and trying that I'm pretty sure my coil is weak. I'll have moments when It runs fine and then it will start spitting fuel from the carb. I've noticed when it does that the spark seems to get weak. Has anybody ran into this before? Coil's for this cart are hard to come by.
|
04-22-2015, 09:13 PM | #10 |
Gone Wild
Join Date: Mar 2012
Location: CENTRAL PENNSYLVANIA
Posts: 1,466
|
Re: 1991 ds cranks but wont start
yeah they are hard to come by but someone on here knows where to get them i just cannot remember who or where
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G22 Starting Issue - Cranks and Cranks for Initial Start | Gas Yamaha | |||
89 Marathon cranks but won't start | Gas EZGO | |||
91 marathon cranks wont start | Gas EZGO | |||
2002 EZGO GAS Cranks but WON'T START! | Gas EZGO | |||
No Start-just Cranks-98 Ezgo Gas | Gas EZGO |