|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-10-2019, 04:33 PM | #1 |
Not Yet Wild
Join Date: Mar 2019
Location: Audubon, Pa
Posts: 58
|
Did I really get new batteries installed??
I bought a 36V 2002 Club Car DS from someone.
Gave me a receipt dated 2/9/19 that he got 6 CR220 batteries and installed in the cart. They looked new. When I went to buy the cart, was clean, ran good, avg speed up his street. DONE DEAL. Got home and drove to work (right around the block) but I seemed to lose speed. When I got home I barely made it up my driveway. So I checked out who could help.. I bought a 36V meter from cartsunlimited Asked allot of questions about voltages and I was unfortunately told the batteries are bad. SO ARE THEY??? I checked the battery voltages this morning all above 7.1, but the meter was only reading 31. So I disconnected everything and started over. As I connected each battery I made sure I was getting around 7V, then 14, then 21.(on my volt meter) When I finished I connected the 36V meter and ended with 47.7 Volts. Took the cart for a ride, 36V, drop to 34 on a steady straightaway. Downhill went to 37+V Then came back to house and up the driveway. Bottomed out at 32.1 and was barely moving, if 2 people in it, don't think I would of made it. So, what else can I check the make sure before I go after the seller for bad batteries. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-10-2019, 04:44 PM | #2 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: Did I really get new batteries installed??
Your meter readings are all over the map. Make sure your cables are installed correctly and let the charger run until it shuts off.
|
03-10-2019, 04:47 PM | #3 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: Did I really get new batteries installed??
to BGW!
|
03-10-2019, 04:59 PM | #4 |
Not Yet Wild
Join Date: Mar 2019
Posts: 13
|
Re: Did I really get new batteries installed??
If you buy a load tester, you can test the batteries out.. If the 6V batteries are dropping below 5.4V under load, then they are getting quite weak. That doesn't sound like that's the problem. Check all your wiring to make sure the connections are tight. Check the wiring to the motor as well
Sent from my SM-G935V using Tapatalk |
03-10-2019, 05:04 PM | #5 |
Gone Wild
Join Date: Jan 2016
Location: Central Florida
Posts: 296
|
Re: Did I really get new batteries installed??
Also look for date stamp on battery terminals. Letter and a number. A-L signifying month and number of last number in year produced.
|
03-10-2019, 05:05 PM | #6 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,227
|
Re: Did I really get new batteries installed??
Are you sure that you aren't suppose to have 8V batteries in it? Do you have a bank of resistors or a controller to control the speed?
|
03-10-2019, 06:28 PM | #7 |
Not Yet Wild
Join Date: Mar 2019
Location: Audubon, Pa
Posts: 58
|
Re: Did I really get new batteries installed??
V-Glide 36V with resistors
|
03-10-2019, 06:48 PM | #8 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Did I really get new batteries installed??
First and foremost check the date code, then if they are running a little low (weak) it is not at all unusual for new batteries until the are broken in (seasoned) so you get the longevity you expect. This is a noticeable difference over the first 30-50 charges. See the attached for a little more details.
|
03-10-2019, 07:14 PM | #9 |
Not Yet Wild
Join Date: Mar 2019
Location: Audubon, Pa
Posts: 58
|
Re: Did I really get new batteries installed??
DATE Code I found on 6 batteries.
K06182L1 1234 K06182L1 1233 K06182L1 1232,3,4,5 |
03-10-2019, 07:24 PM | #10 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Did I really get new batteries installed??
Look stamped in the battery post. or in the corner of the battery case. Should be like B/19 or A-19 or something similar. Those equate to Feb/2019 and Jan-2019 respectively.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
new batteries installed but now doesn't run | Electric EZGO | |||
DS IQ will not run, NEW batteries just installed | Electric Club Car | |||
Batteries Installed Backward | Electric EZGO | |||
Just Installed New Batteries - What do I need to do Next? | Electric EZGO | |||
Installed new batteries | Electric Club Car |