SOC showing no charge

CAPTAINASU · 10-24-2015, 07:42 PM

I have a 2008 RXV 48v that I just acquired. All was well except for a bad headlight switch. After I replaced the switch my SOC meter has the yellow light on showing the batteries are "dead" even though they were fully charged 30 minutes earlier. The headlights, radio, etc. are all working but the cart will not move.

Could I have blown a fuse or something? I have looked everywhere obvious and I didn't see anything other than an 10v fuse under the tow/run switch and some fuses connected to the 12v system.

Given I went from showing full charge and running and showing no charge and not running I am hoping this is something simple.

This is my first electric cart so I am at a loss as to where to start

Thanks!

cgtech · 10-24-2015, 07:55 PM

If your switch is wired to the key switch, or soc meter (or anywhere other than the factory intended), you likely fried your controller.. A big "oopsie" you will not want to repeat (when you find out how much thats gonna cost ya).

CAPTAINASU · 10-24-2015, 08:01 PM

That's probably what I did as I was poking around there blind.

How do I verify? Is this something I can do myself? and how much are we talking about?

Thanks

10-25-2015, 03:56 AM

RXV 48 Volt AC Controller Assembly $1,119.00

https://shop.ezgo.com/products/RXV-4...-Assembly.html

10-24-2015, 07:42 PM	#1
CAPTAINASU Not Yet Wild Join Date: Jan 2013 Posts: 18	SOC showing no charge I have a 2008 RXV 48v that I just acquired. All was well except for a bad headlight switch. After I replaced the switch my SOC meter has the yellow light on showing the batteries are "dead" even though they were fully charged 30 minutes earlier. The headlights, radio, etc. are all working but the cart will not move. Could I have blown a fuse or something? I have looked everywhere obvious and I didn't see anything other than an 10v fuse under the tow/run switch and some fuses connected to the 12v system. Given I went from showing full charge and running and showing no charge and not running I am hoping this is something simple. This is my first electric cart so I am at a loss as to where to start Thanks!
CAPTAINASU Not Yet Wild Join Date: Jan 2013 Posts: 18

10-24-2015, 07:55 PM	#2
cgtech Over This Interview Is... Join Date: Jun 2012 Location: AZ Posts: 17,449	Re: SOC showing no charge If your switch is wired to the key switch, or soc meter (or anywhere other than the factory intended), you likely fried your controller.. A big "oopsie" you will not want to repeat (when you find out how much thats gonna cost ya).

10-24-2015, 08:01 PM	#3
CAPTAINASU Not Yet Wild Join Date: Jan 2013 Posts: 18	Re: SOC showing no charge That's probably what I did as I was poking around there blind. How do I verify? Is this something I can do myself? and how much are we talking about? Thanks
CAPTAINASU Not Yet Wild Join Date: Jan 2013 Posts: 18

10-25-2015, 03:56 AM	#4
crash test dummy Guest Posts: n/a	Re: SOC showing no charge RXV 48 Volt AC Controller Assembly $1,119.00 https://shop.ezgo.com/products/RXV-4...-Assembly.html
crash test dummy Guest Posts: n/a

Similar Threads
Thread	Forum
Got oil showing up in the air box of your lifted cart?	Gas EZGO
Clubcar web not showing DS cars !!	Electric Club Car
State of charge meter showing 1 bar	Electric EZGO
How Come my Pic is not showing up next to my name?	Test Post
98 ezgo charge meter not showing actual charge	Electric EZGO

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum