07-06-2018, 02:27 PM | #1 |
Not Yet Wild
Join Date: Oct 2017
Location: Greenville, MS
Posts: 7
|
2000 Losing Power
Engine starts when cold and runs good. As engine gets heated, loses power and starts to backfire. Eventually stops. Exhaust is smoky and smells like raw fuel. when engine stops.
I have already replaced fuel pump, fuel filter and carb. Ran compression test while engine was still hot and #1 cylinder 138, #2 cylinder 150. Any ideas would be helpful. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-06-2018, 02:40 PM | #2 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 2000 Losing Power
Adjust the valves to .004 clearance.
|
07-06-2018, 03:49 PM | #3 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: 2000 Losing Power
If that was a aftermarket carb? I will bet your going to have to take it apart and clean it. Those China carbs are bad about leaving milling debris inside the carb.
Had to clean mine twice before it worked correctly! |
07-07-2018, 09:04 AM | #4 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: 2000 Losing Power
Also the big difference in the compression would indicate valves out of adjustment.
|
07-07-2018, 09:06 AM | #5 |
Not Yet Wild
Join Date: May 2017
Posts: 25
|
Re: 2000 Losing Power
I am having a similar issue. What do you need to run a compression test and you hook it up where the spark plugs go correct?
Sent from my LGLS676 using Tapatalk |
07-07-2018, 09:12 AM | #6 | |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: 2000 Losing Power
Quote:
Screw it in and turn the engine over 3 or 4 times and you have it. Most part stores or any place that sell tools will have them. |
|
07-09-2018, 01:18 PM | #7 |
Not Yet Wild
Join Date: Oct 2017
Location: Greenville, MS
Posts: 7
|
Re: 2000 Losing Power
OK finally had a chance to work on cart again. Adjusted valves and cleaned new carb and put everything back on. Runs a little better, but still has no power when it gets up to operating temp, and still backfires when you let off the throttle to let it come to a stop. Turns over good, but won't start back up until cools down. (about 10 minutes)
|
07-09-2018, 07:56 PM | #8 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 2000 Losing Power
Run it and once it starts acting up inspect the plugs if they are wet it's an ignition issue if they are dry it's a fuel issue we can further diagnose from there
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Losing power | Electric EZGO | |||
Losing power | Electric EZGO | |||
2000 ST350 Losing juice? | Gas EZGO | |||
82 G1 losing power | Gas Yamaha | |||
DS Losing Power | Electric Club Car |