|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-24-2021, 11:15 AM | #1 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
EZGO TXT intermittent forward and reverse
New to me 36 volt golf cart with Date Code A1709. I'm reading that means its a 2009. Trojan Black batteries that are new and fully charged. Tested with volt meter to 38.6 volts. Yesterday evening the cart quit fulling moving in forward and reverse. It will sometimes move 6 ft or so in each direction and then sometimes will not move at all. I can distinctly hear the solenoid clicking. All wires are in good condition. Cart has a Curtis controller. Ran it for a couple of miles this morning and then after returning home and parking the cart and trying to use it again about 20 minutes later it wouldn't move. Any help would be appreciated. I'm thinking it is either the FNR rocker switch or the solenoid.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-24-2021, 12:18 PM | #2 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: EZGO TXT intermittent forward and reverse
If it still has the reverse buzzer put it in diagnostic mode and listen for codes. Put the fnr switch in N. Turn key on and switch from N to R five times ending in N. It should then beep 1-4 times depending on what speed chip is in it. Then might beep some codes. Now push the go pedal and listen.
|
10-24-2021, 12:49 PM | #3 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
Re: EZGO TXT intermittent forward and reverse
just attempted to do this and didn't hear any beeps just the reverse buzzer when in R.
|
10-24-2021, 12:53 PM | #4 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: EZGO TXT intermittent forward and reverse
Flip it to tow then back to run and try again. Remember to end in N
|
10-24-2021, 01:17 PM | #5 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: EZGO TXT intermittent forward and reverse
Text at bottom of attached label tells you how.
|
10-24-2021, 02:03 PM | #6 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
Re: EZGO TXT intermittent forward and reverse
Still no bueno on the diagnostic mode. Below is the procedure I followed.
Put cart in tow/maintenance mode. Waited 20 minutes. Put cart in run mode. Waited 30 seconds. Cart key was off the whole time with the FNR switch in N. Switched key to ON, toggled FNR switch from N to R, N to R, N to R, N to R, N to R and back to neutral. Waited 10 seconds to see if I would hear a verification of cart in diag mode, did not hear any beeps. Fully depressed the Go pedal and still heard no beeps. |
10-24-2021, 02:21 PM | #7 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
Re: EZGO TXT intermittent forward and reverse
|
10-24-2021, 03:36 PM | #8 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
Re: EZGO TXT intermittent forward and reverse
I got the cart to go into Diagnostic mode. I heard 4 beeps to indicate it is in diag mode. What needs to be done after the cart goes into diag mode? I pressed on the go pedal but didn't hear any additional beeps.
|
10-25-2021, 08:26 AM | #9 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: EZGO TXT intermittent forward and reverse
The 4 beeps is telling you the freedom chip is installed. Reverse at least works on the fnr switch because you are hearing the beeper. No movement sounds like a bad solenoid but I would think that you would get beeps for that.
|
10-25-2021, 08:50 AM | #10 |
Not Yet Wild
Join Date: Oct 2021
Posts: 22
|
Re: EZGO TXT intermittent forward and reverse
I do get audible clicks from the solenoid when pressing on the Go pedal.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1998 Club Car no reverse. Forward Intermittent. | Electric Club Car | |||
2001 EZGO TXT 36V Elec intermittent forward/reverse | Electric EZGO | |||
2010 EZ-GO RXV 48v Electric - intermittent forward & reverse | Electric EZGO | |||
99 electric club car clicks and won't move. intermittent forward and reverse | Electric Club Car | |||
intermittent spark forward and reverse G1 | Gas Yamaha |