RXV rear end oil fill

Paul08RXV · 03-22-2015, 08:12 PM

yes - use that transfer pump referenced above - OR - I used a piece of plastic tubing and squeezed it in from an attached inverted bottle. 3 OZ of the amount should be antislip additive for an RXV rear end. I used Quaker Stated synthetic fluid (90w140).

As I remember it was 22oz of 90w140 plus 3oz of antislip - mixed it up in the original bottle, cut off the pointed cap and pushed on the plastic tubing. Tubing was about 1/2 inch I think.

gruelens · 03-24-2015, 10:38 PM

I am the OP and this is the result of my job.

Pulled the rear differential pan and drained completely.
Re-installed pan with RTV silicone gasket maker as a seal.
Mixed 25 oz of oil and 2 oz of friction modifier, as stated in manual under capacities.
Used hand pump to push oil mix into rubber plug hole in differential.

Note: 27 oz (25+2) did not drain out. Neither did my 27 oz of new fit back in. I would guess the the capacity at approx. 22oz. total. It is full to the plug with new synthetic oil and friction modifier.

Thanks to everyone here for your advice and help.

BP Clayton · 08-29-2020, 03:45 PM

Can I fill the differential through the vent hole?

cgtech · 08-29-2020, 03:49 PM

Yes, its possible, but itll be slow.

thatldopig · 08-30-2020, 03:04 PM

Here's what I did last week - worked perfect for me: https://www.buggiesgonewild.com/show...93#post1754193

03-22-2015, 08:12 PM	#11
Paul08RXV Not Yet Wild Join Date: May 2013 Location: Ontario, Canada Posts: 14	Re: RXV rear end oil fill yes - use that transfer pump referenced above - OR - I used a piece of plastic tubing and squeezed it in from an attached inverted bottle. 3 OZ of the amount should be antislip additive for an RXV rear end. I used Quaker Stated synthetic fluid (90w140). As I remember it was 22oz of 90w140 plus 3oz of antislip - mixed it up in the original bottle, cut off the pointed cap and pushed on the plastic tubing. Tubing was about 1/2 inch I think.

03-24-2015, 10:38 PM	#12
gruelens Not Yet Wild Join Date: Nov 2014 Posts: 56	Re: RXV rear end oil fill I am the OP and this is the result of my job. Pulled the rear differential pan and drained completely. Re-installed pan with RTV silicone gasket maker as a seal. Mixed 25 oz of oil and 2 oz of friction modifier, as stated in manual under capacities. Used hand pump to push oil mix into rubber plug hole in differential. Note: 27 oz (25+2) did not drain out. Neither did my 27 oz of new fit back in. I would guess the the capacity at approx. 22oz. total. It is full to the plug with new synthetic oil and friction modifier. Thanks to everyone here for your advice and help.
gruelens Not Yet Wild Join Date: Nov 2014 Posts: 56

08-29-2020, 03:45 PM	#13
BP Clayton Not Yet Wild Join Date: Jul 2020 Posts: 14	Re: RXV rear end oil fill Can I fill the differential through the vent hole?
BP Clayton Not Yet Wild Join Date: Jul 2020 Posts: 14

08-29-2020, 03:49 PM	#14
cgtech Over This Interview Is... Join Date: Jun 2012 Location: AZ Posts: 17,449	Re: RXV rear end oil fill Yes, its possible, but itll be slow.

08-30-2020, 03:04 PM	#15
thatldopig Not Yet Wild Join Date: Aug 2020 Location: Buckhead, GA Posts: 12	Re: RXV rear end oil fill Here's what I did last week - worked perfect for me: https://www.buggiesgonewild.com/show...93#post1754193

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Forum
how to fill a spicer 012AJ184 1 73069 g01 rear end with oil?	Electric EZGO
help, where is the rear end fill up spot	Electric EZGO
how much oil and proper fill level rear end?	Electric Club Car
1989 Rear Differential Fill/Drain Plug?	Gas EZGO
Rear Dif. Fill Level	Electric EZGO