|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-27-2016, 06:25 PM | #1 |
Not Yet Wild
Join Date: Aug 2016
Posts: 2
|
Ezgo pads with Alltrax 400 controller bucking at full throttle
Good afternoon. I have a question that I'm hoping you can help us with. We have an ezgo cart with the above controller on it. Its the model DCX400R19 by Alltrax. It's been working great till just recently. The cart seems to drive just fine until you go full throttle. At that point it "bucks" and you can hear the solenoid clicking on and off rapidly. The cart has new batteries and cables. The problem was occurring with the old batteries and cables as well. Do you have any ideas what to check and procedures? The controller programming has never been touched either.
Thank you so much for any assistance you can provide. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-30-2016, 08:36 PM | #2 |
Not Yet Wild
Join Date: Aug 2016
Posts: 2
|
Re: Ezgo pads with Alltrax 400 controller bucking at full throttle
anyone?
|
08-30-2016, 08:42 PM | #3 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,125
|
Re: Ezgo pads with Alltrax 400 controller bucking at full throttle
I would consult with Alltrax. They have good customer support.
|
08-30-2016, 08:58 PM | #4 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
|
Re: Ezgo pads with Alltrax 400 controller bucking at full throttle
It's most likely a battery problem. Full throttle calling for max amp flow and solenoid dropping in and out sounds like a battery problem. Do not let this continue. It will damage the solenoid and It may break an axle, suspension perch, or strip a rear hub. Take a battery voltage reading at a standstill and then at wide open throttle while the cart is bucking. Post those two readings here.
|
08-30-2016, 11:19 PM | #5 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo pads with Alltrax 400 controller bucking at full throttle
Yea, battery or one or more cables too small and causing the voltage to drop too much at max current.
Bob |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Yamaha G1 Only Runs with full choke and full Throttle | Gas Yamaha | |||
Alltrax XCT custom controller & throttle settings | Electric Club Car | |||
New to EZGO, tuneup but can't get full throttle | Gas EZGO | |||
yamaha g2 bogs at half throttle through full throttle | Gas Yamaha | |||
Alltrax 500A controller...cant get 100% throttle | Electric Club Car |