|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-04-2011, 07:49 AM | #1 |
Gone Wild
Join Date: Dec 2009
Posts: 251
|
04 ez go suddendly lost power
04 ez go pds was going fine then it just lost power goes about half speed now ,checked battery pack has 37.4 volts full power in reverse batterys check fine under load tester any help appreciated
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-06-2011, 10:26 PM | #2 |
steeplejack x
Join Date: Jan 2007
Location: Republic of Texas
Posts: 3,382
|
Re: 04 ez go suddendly lost power
Run diagnostic?
|
09-06-2011, 11:12 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 04 ez go suddendly lost power
PDS Diagnostic Mode =
PDS Diagnostic mode can be entered with the cart stopped key 'off' though 5 consecutive neutral > reverse selections. Then pause = about 2 seconds after the 5th selection the reverse buzzer will emit a series of beeps... like 3 & 2. Report what your cart reports here. To exit diagnostic mode turn the maintenance switch from run to tow and back again |
09-08-2011, 05:20 PM | #4 |
Gone Wild
Join Date: Dec 2009
Posts: 251
|
Re: 04 ez go suddendly lost power
after running diagnostic test i get 4 very fast beeps ,so fast its hard too count them after 3 times its 4 fast beeps thanks scotty b
|
09-08-2011, 06:23 PM | #5 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 04 ez go suddendly lost power
Maybe it is 3-1 Solenoid driver failure. You can check the solenoid activation circuit, this is also a possible controller failure code.
How the Solenoid works: The solenoid is a HD on/off switch or Contactor the connection is made /broken between the 2 large terminals. The 2 small terminals are the activation circuit. Typically one terminal will have a constant negative connection to the pack. When Positive power is applied to the second small terminal the contact is drawn up against the spring to make contact. When power from either side of the activation circuit is removed then contact is released and the spring pushes it away interrupting the circuit ...It doesn't matter which small terminal is neg or pos on the activation circuit so long as you have both.... The solenoid is just a switch making and breaking the contact between the 2 large posts when the 2 small posts have pack voltage. I hope this helps. |
09-12-2011, 06:53 PM | #6 |
Gone Wild
Join Date: Dec 2009
Posts: 251
|
Re: 04 ez go suddendly lost power
it was the solenoid thanks scotty b ,if i could only get my club car going it would be great solenoid tests good cntroller tests good and other tests ?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
96 Club Car lost power | Electric Club Car | |||
battery power lost | Electric Club Car | |||
WHY??? Motor got hot and lost most power | Electric EZGO | |||
Lost power | Electric Club Car | |||
Lost Power | Electric EZGO |