|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
09-23-2018, 03:22 PM | #1 |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
2014 Precedent Movement Issues - Video
Hey Guys,
New to golf carts, just picked this up not long ago. Its a 2014 Club Car Precedent. I recently pulled the motor and did the bandit upgrade by Plum Quick. Has worked flawlessly for the last week. Today I replaced the rear springs with HD ones. When I started it up, and reversed I heard a noise (can't recall if it was a clunk or a pop) then it would no longer move. I shot a quick video of the issue. Thanks again in advance for the help! https://www.youtube.com/watch?v=ay4_UrZbmU4 |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-23-2018, 04:21 PM | #2 |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
Re: 2014 Precedent Movement Issues - Video
Two side notes:
It hadn't happened often but I had suspected the Forward/Reverse switch to be going bad, as it would sometimes take a couple clicks in either direction for it to engage or realize which mode I was trying for. Also just now when messing with it the solenoid was not clicking over each time. Thanks Brad |
09-23-2018, 04:25 PM | #3 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2014 Precedent Movement Issues - Video
Check the Controller, the quick connects for F1 or F2 came loose.
|
09-23-2018, 04:35 PM | #4 | |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
Re: 2014 Precedent Movement Issues - Video
Quote:
Do you think this is a problem with the motor? |
|
09-23-2018, 04:57 PM | #5 |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
Re: 2014 Precedent Movement Issues - Video
|
09-23-2018, 06:21 PM | #6 |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
Re: 2014 Precedent Movement Issues - Video
The solenoid seems to be clicking over about 50% of the time now.
|
09-23-2018, 07:09 PM | #7 |
Not Yet Wild
Join Date: Sep 2018
Location: Mount Holly, NC
Posts: 13
|
Re: 2014 Precedent Movement Issues - Video
Sorry to keep throwing things at this but I feel the more information I provide the better. I didn't disconect the batteries while working on the cart as it was just the rear suspension. Not sure if that would have caused any issues. I don't remember any major shorts or anything.
|
09-23-2018, 09:25 PM | #8 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 2014 Precedent Movement Issues - Video
With the batteries connected, Tow/Run switch in Run; place the black (–) probe on packs main Negative post and the red (+) probe on the yellow wire at the 3-pin connector near the MCOR. (The reading should be approximately ~0.32vdc to .5vdc with the pedal up). Slowly press the Go Pedal and the readings should increase until it reaches ~4.65vdc or higher when the pedal is fully pressed. (Anything less than 4.60vdc and you are not reaching full throttle). If the reading is erratic or jumps all over the place it is a bad MCOR output signal..... Get one here https://www.revolutiongolfcars.com/mcors
If the reading is correct, we can check the controller output next as that will most likely be your problem.... |
09-23-2018, 09:53 PM | #9 | |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,226
|
Re: 2014 Precedent Movement Issues - Video
The first thing I thought of was that you may have shorted two of the motor terminals when changing the spring. But you said.
Quote:
|
|
09-23-2018, 09:54 PM | #10 | |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 2014 Precedent Movement Issues - Video
Quote:
Is it working when you spin the wheel every time? Really sounds like a motor issue to me. Brushes or something. Club Car DS driver’s club #59 |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2014 TXT electric motor issues | Electric EZGO | |||
2014 carryall 550 EFI issues | Gas Club Car | |||
09 precedent 3 clicks before any movement?? | Electric Club Car | |||
2014 build WHITE MAMBA Triple Video | Electric EZGO | |||
Engine Swap Starting Issues... (Video) | Gas Yamaha |