lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 05-16-2018, 12:57 PM   #1
jonr3
Gone Wild
 
jonr3's Avatar
Harley Davidson
 
Join Date: Jan 2016
Location: Hickory, NC
Posts: 702
Default New Batteries - Breaking In/Seasoning Question

So I bit the bullet and got a new set of T875s for my '14 CCP. I've read everything I could find about breaking in the new batteries. From what I could tell, I should drive it no more than to 75% charge (about 49.75v) and then let it recharge completely.

Here's my problem: I don't have time to drive it enough to get it down to 75%. I'll drive it around after work as much as possible but I can usually only get it down to about 50.1v or so. Is this going to be bad for my batteries in the long run? Thanks!
jonr3 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 05-16-2018, 01:56 PM   #2
NCPW
Just Gone
 
NCPW's Avatar
Club Car
 
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
Default Re: New Batteries - Breaking In/Seasoning Question

When breaking in new batteries you don't have to drive them down to 75-80% SOC, just don't let them get below that mark to get the most out of them.

Every time you use the cart, whether it's for 15 minutes or an hour, put it back on the charger when done.
NCPW is offline   Reply With Quote
Old 05-16-2018, 02:08 PM   #3
NoleFan4Ever
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 17,477
Default Re: New Batteries - Breaking In/Seasoning Question

Check this out too. http://www.buggiesgonewild.com/elect...batteries.html
NoleFan4Ever is offline   Reply With Quote
Old 05-16-2018, 02:12 PM   #4
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: New Batteries - Breaking In/Seasoning Question

How much You drive is not as important as how you drive.

Avoid large current demands on the batteries until the plates have had time to fully form.

As mentioned, fully charge it at the end of any day You drive it, regardless if 5 minutes or 5 hours.
Sergio is offline   Reply With Quote
Old 05-16-2018, 02:40 PM   #5
jonr3
Gone Wild
 
jonr3's Avatar
Harley Davidson
 
Join Date: Jan 2016
Location: Hickory, NC
Posts: 702
Default Re: New Batteries - Breaking In/Seasoning Question

Quote:
Originally Posted by NCPW View Post
When breaking in new batteries you don't have to drive them down to 75-80% SOC, just don't let them get below that mark to get the most out of them.

Every time you use the cart, whether it's for 15 minutes or an hour, put it back on the charger when done.
Good to know. I put it on the charger every night without fail. Thanks!
jonr3 is offline   Reply With Quote
Old 05-16-2018, 02:43 PM   #6
jonr3
Gone Wild
 
jonr3's Avatar
Harley Davidson
 
Join Date: Jan 2016
Location: Hickory, NC
Posts: 702
Default Re: New Batteries - Breaking In/Seasoning Question

Quote:
Originally Posted by NoleFan4Ever View Post
Thanks! I've read that thread and another long one I found. I'm putting it on the charger every night and checking the water at least once a week for now.
jonr3 is offline   Reply With Quote
Old 05-16-2018, 02:46 PM   #7
jonr3
Gone Wild
 
jonr3's Avatar
Harley Davidson
 
Join Date: Jan 2016
Location: Hickory, NC
Posts: 702
Default Re: New Batteries - Breaking In/Seasoning Question

Quote:
Originally Posted by Sergio View Post
How much You drive is not as important as how you drive.
Avoid large current demands on the batteries until the plates have had time to fully form.
As mentioned, fully charge it at the end of any day You drive it, regardless if 5 minutes or 5 hours.
Hi Sergio,
What would be considered large current demands? Across the street from my house, there is a small subdivision with some hills. I have a volt meter on my dash to monitor my charge while driving...
jonr3 is offline   Reply With Quote
Old 05-16-2018, 02:52 PM   #8
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: New Batteries - Breaking In/Seasoning Question

I would say over 100 amps continuous or over 300 amps peak.

If You see your voltmeter dropping below 44v, lift your foot off the pedal a little.
Sergio is offline   Reply With Quote
Old 05-16-2018, 03:02 PM   #9
jonr3
Gone Wild
 
jonr3's Avatar
Harley Davidson
 
Join Date: Jan 2016
Location: Hickory, NC
Posts: 702
Default Re: New Batteries - Breaking In/Seasoning Question

Quote:
Originally Posted by Sergio View Post
I would say over 100 amps continuous or over 300 amps peak.
If You see your voltmeter dropping below 44v, lift your foot off the pedal a little.
Roger that! I'll keep an eye on it. Thanks!
jonr3 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
New T-875 Batts are in the CCP - Seasoning/Cycling? Electric Club Car
Breaking in new 6v interstate batteries Electric EZGO
Breaking in new batteries Electric EZGO
Charging / breaking in new batteries? Electric Club Car
breaking in new batteries Electric Club Car


All times are GMT -5. The time now is 07:40 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.