2006 TXT won’t go

[racertoms27]

Hi all. Had an issue develop on our last camping trip. Cart seemed to be working perfectly. It was parked mostly in the shade by our campsite. One time we ventured out and had it parked in the sun and the air temp was every bit of 95 degrees. It was fine driving to the destination but would not move when we got back to it about 1 1/2 hours later. Had lights, SOC meter (one of ScottyB’s) back up alarm worked. Tried switching it to tow and back, but still nothing. Solenoid didn’t make a sound.
An on site Cart repair service came and towed it and kept it overnight. Got a call early AM and was told after charging it all night, they drove it around in the morning and said it was fine. Picked it up, used it all day and it was fine. Loaded it up to come home the following day, about a 4 1/2 trip, went to unload it, same problem came up.
In both instances it was showing 37.1 on the SOC, It’s a 36v Cart.
My question is, could being out in heat and sun cause a problem or show an issue that you wouldn’t see otherwise?


Sent from my iPhone using Tapatalk

[nickdalzell1]

Since Backup Beeper works, try turning key OFF, go forward/reverse five times and stop in between positions. You should then hear a speed code beeping sequence (beep once for no speed upgrade, two for mild hill, three for steep hill, four for freedom mode). try driving it, when it fails, you should hear a series of beeps, a pause, then another series of beeps. There's a chart on the controller cover where your Run/Tow switch is to tell you what they mean.

FYI an overtemp code will just put the car in limp mode, not be entirely dead.

[racertoms27]

Thank you for that information. Of course now it is functioning just fine.


Sent from my iPhone using Tapatalk