|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
12-23-2022, 08:35 PM | #1 |
Not Yet Wild
Join Date: Jan 2012
Location: Palm Bay, Florida
Posts: 45
|
2010 Gas Club Car Carryall 2 wont start
NEED HELP!!!
2010 Gas Club Car Turf/Carryall2 will not start. I have no power crossing through Solenoid when pedal is depressed. I have key switch power to solenoid and I have even replaced the Solenoid. I checked all wires through diagram and replaced the micro switches. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-24-2022, 12:12 PM | #2 |
Not Yet Wild
Join Date: Jan 2012
Location: Palm Bay, Florida
Posts: 45
|
Re: 2010 Gas Club Car Carryall 2 wont start
Can anyone Help. I’m at a loss
|
12-24-2022, 12:32 PM | #3 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,174
|
Re: 2010 Gas Club Car Carryall 2 wont start
|
12-24-2022, 01:22 PM | #4 |
Not Yet Wild
Join Date: Jan 2012
Location: Palm Bay, Florida
Posts: 45
|
Re: 2010 Gas Club Car Carryall 2 wont start
Can anyone Help. I’m at a loss
|
12-24-2022, 04:45 PM | #5 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,682
|
Re: 2010 Gas Club Car Carryall 2 wont start
Check this.
You should have power at the blue wire at solenoid with key on. With shifter in gear and pedal depressed you should have ground at the orange wire. See which is missing |
12-26-2022, 01:11 PM | #6 |
Not Yet Wild
Join Date: Jan 2012
Location: Palm Bay, Florida
Posts: 45
|
Re: 2010 Gas Club Car Carryall 2 wont start
Yea power at blue wire and no ground at orange which goes from opposite post to the micro switch with green wire
|
12-26-2022, 03:07 PM | #7 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,682
|
Re: 2010 Gas Club Car Carryall 2 wont start
Sounds like a bad solenoid to me.
What happens if you manually apply power to one small post and ground to the other? Starter should spin. If not replace the solenoid. |
12-26-2022, 03:35 PM | #8 | |
Gone Wild
Join Date: May 2022
Location: Pensacola, FL
Posts: 291
|
Re: 2010 Gas Club Car Carryall 2 wont start
Quote:
|
|
12-26-2022, 08:55 PM | #9 |
Not Yet Wild
Join Date: Jan 2012
Location: Palm Bay, Florida
Posts: 45
|
Re: 2010 Gas Club Car Carryall 2 wont start
I ordered and replaced the solenoid with one from Amazon that was supposed to be for that year. With key off I get over 12 volts on both small posts.
|
12-26-2022, 09:42 PM | #10 |
Nincompoop village idiot
Join Date: Apr 2018
Location: Michigan
Posts: 9,682
|
Re: 2010 Gas Club Car Carryall 2 wont start
Sorry just re-read your last post. You said no ground at the orange. My fault.
That goes through the limit switches. Specifically the service mode switch and the pedal activation switch. Look at the diagram above. Make SURE the correct wires are on the correct posts and the yellow service mode cam on the back of the shifter is making contact with the limit switch that has the black, green, white wires. If all that is good, then follow the circuit back and see where you’re losing ground. It should go from the orange solenoid wire to the orange wire at the pedal microswitch. On the other side of that microswitch it is green where it runs to the service mode microswitch. From there it runs into the black wire which runs straight to ground. Just use your meter set to continuity so it beeps if you touch the probes together. Hook one probe to the negative battery terminal and check each of those wires (orange, green, black) for continuity to ground. All 3 of them should beep with key switch turned ON and pedal depressed. If none of them beep then the black wire is not grounded and it should be. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Gas Club Car Carryall 2 wont start | Big Block Talk! | |||
Club car carryall take a while to start | Gas Club Car | |||
2010 TXT ezgo wont move/start | Electric EZGO | |||
2002 carryall club car with 2010 Kawasaki engine not starting | Gas Club Car | |||
1997 Gas Carryall 2 Wont Start | Gas Club Car |