|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-08-2019, 02:01 PM | #1 |
Not Yet Wild
Join Date: Sep 2017
Posts: 30
|
2013 precedent won’t go at full throttle
I bought a disassembled 2013 precedent that was a bit of a basket case. The wiring harness has been hacked up so I ordered and installed a new harness and got it moving. The problem is that it works fine up to around 1/2 to 3/4 fill throttle on the pedal, but any more and it does nothing and acts like you aren’t on the throttle at all. I have swapped the motor, speed sensor, controller and mcor from another cart that runs fine but I’m still having the same problem even with those parts swapped for parts that I know are good. What else could be wrong?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-11-2019, 11:41 PM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 2013 precedent won’t go at full throttle
You need to verify the MCOR signal to the Controller. Could be in the linkage....
With the batteries connected, Tow/Run switch in Run; place the black (–) probe on packs main Negative post and the red (+) probe on the yellow wire at the 3-pin connector near the MCOR. (The reading should be approximately ~0.32vdc to ~0.5vdc with the pedal up). Slowly press the Go Pedal and the readings should increase until it reaches ~4.65vdc or more when the pedal is fully pressed. (Anything less than 4.60vdc and you are not reaching full throttle - verify the linkage). If the reading is erratic or jumps all over the place it is a bad MCOR output signal..... |
04-12-2019, 05:21 AM | #3 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2013 precedent won’t go at full throttle
You will also get that behavior if it is an Excel system (gray curtis controller) and you purchased an IQ harness.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
precedent shuts down at full throttle | Electric Club Car | |||
Yamaha G1 Only Runs with full choke and full Throttle | Gas Yamaha | |||
Precedent shutdown at full throttle. Excel | Electric Club Car | |||
06 CC Precedent moves side to side at full throttle. | Gas Club Car | |||
2005 Precedent IQ Going Into Limp Mode At Full Throttle | Electric Club Car |