|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-25-2011, 02:38 AM | #1 |
Not Yet Wild
Join Date: Oct 2010
Posts: 41
|
88 ezgo charging problem
Battery not charging while running what do I test for and voltage regulator can I use and automotive one if so what would it fit Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-25-2011, 07:38 AM | #2 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: 88 ezgo charging problem
Here is the procedure, before you start make sure that the ground points on the frame and very clean and tight this is the main cause of all problems. In addition there must be a strap between the ground point on the frame and the engine block. If this checks out then :-
1) Check for loose, broken wiring, using a use a fully charged battery, taking note of battery voltage. 2) Raise rear of cart and attach a volt meter between the regulator's red and black wires. 3) Start engine and run at mid speed, making note of the meter reading. 4) Reading should be between 14 to 16 volts. 5) If no rise in voltage, disconnect green wire from starter/gen. and temporarily ground to frame. 6) If voltage rises within specs, replace voltage regulator. 7) If reading is above specs in step 4 check for a grounded green wire from the starter/gen. When you remove the green DF wire from the starter use a thin wrench under the wire to stop the stud spinning. Dave |
07-25-2011, 04:38 PM | #3 |
Not Yet Wild
Join Date: Oct 2010
Posts: 41
|
Thanks I will check it out tonight I have the battery charging now
|
07-26-2011, 11:06 PM | #4 |
Not Yet Wild
Join Date: Oct 2010
Posts: 41
|
Ok it's charging now I think I am going to put another battery in for the lights and the radio worked fine durning the day but running the lights and stuff at night and making short trips I guess just killed it might try a motorcycle battery or just put a bigger battery in
|
07-27-2011, 08:34 AM | #5 |
Gone Wild
Join Date: Feb 2011
Posts: 1,515
|
Re: 88 ezgo charging problem
I'm using a regular car battery and it works great. As always make sure all grounds are clean and secure.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Another 48V Charging Problem | Electric Club Car | |||
89 EZGO Charging Problem | Gas EZGO | |||
Charging problem | Electric Club Car | |||
charging problem, 96 EZGO TXT | Electric EZGO | |||
Problem with charging? | Electric Club Car |