08-10-2011, 08:27 PM | #1 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
hard starting when warm
I'm stumped on this one. The cart starts up without choke when cold and runs great. I'll pull the cart up to the front yard takes 30 seconds let off the gas, go to restart and it takes awhile to start a minute or so. Carb is clean as can be new fuel line, new filter. New spark plug and air filter .
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-10-2011, 10:30 PM | #2 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
Re: hard starting when warm
O ya its a 97 carryall with the Fe290
|
08-11-2011, 08:32 AM | #3 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: hard starting when warm
when you say clean as clean can be did you tear it apart and go over every little bit of it? you didn,t mention fuelpump......are you sure its ok? they also need torn apart on occasion......but if you didn,t really bite into the carb that just might be where you need to start and its also possible the carb is just plain past its expiration date.............................
|
08-11-2011, 11:32 AM | #4 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
Re: hard starting when warm
I tore the Carb down to nothing and soaked it overnight wasn't really dirty and it was acting up before the Carb cleaning. Fuel pump will shoot a strong 10th foot stream. And the cart has 1400 hours on it
|
08-11-2011, 12:23 PM | #5 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: hard starting when warm
when you had carb apart did you take jets out and run a wire thur all holes? use air compressor to blow thur every opening and port?............hows the spark? good and strong.............................
|
08-11-2011, 02:42 PM | #6 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
Re: hard starting when warm
Yes I used a torch tip cleaner ran it through the jets and the emoltion tube
|
08-12-2011, 07:11 AM | #7 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: hard starting when warm
how about the spark?..............................
|
08-12-2011, 11:07 AM | #8 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
Re: hard starting when warm
Spark is good and strong when I changed the plug it was an bp4es it was white like it was too hot of a plug I put a bp5es in it and closed the gap to 28 made a big difference pulled the plug last nite and it was a nice tan color.
|
08-12-2011, 11:25 AM | #9 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: hard starting when warm
ok when its hard to start does it make any difference if you choke it? has the cart always been like this or is it something new?.......................
|
08-12-2011, 01:49 PM | #10 |
Gone Wild
Join Date: Aug 2010
Location: brooksville fl
Posts: 412
|
Re: hard starting when warm
Choking makes it worse
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Hard starting G1 | Gas Yamaha | |||
Marathon Hard starting once motor gets warm? | Gas EZGO | |||
Hard starting | Gas EZGO | |||
Hard Starting | Gas EZGO | |||
Hard starting 98 w/ 295 | Gas EZGO |