lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 06-15-2018, 03:21 PM   #1
Kenlhlp
Not Yet Wild
 
Join Date: Nov 2015
Posts: 70
Default 2011 Electric Precedent does nothing

I have a electric 2011 Precedent That does nothing.

Battery pack OK. Batteries charge just fine. When in reverse no buzzer. Solenoid does not close. Have tested Solenoid by supplying 48vdc to coil and it closes. Best I can tell by troubleshooting guide MCOR is OK.

Is there a way to bypass the OBC and is there a way to test the controller.

Any help would be appreciated.

Thank you,

Ken
Kenlhlp is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 06-15-2018, 03:46 PM   #2
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: 2011 Electric Precedent does nothing

A bad OBC lockout circuit will do that.

Disconnect the 6-pin connector from the OBC.

Using a large paper clip or a stiff wire jump the White and the Blue wires on the 6-pin connector that is in the cart harness side.

Use some electrical tape on any exposed wire to prevent a short.

Test drive the cart.
Sergio is offline   Reply With Quote
Old 06-26-2018, 11:06 AM   #3
Kenlhlp
Not Yet Wild
 
Join Date: Nov 2015
Posts: 70
Default Re: 2011 Electric Precedent does nothing

Still does nothing. I would assume then the OBC is defective.
Kenlhlp is offline   Reply With Quote
Old 06-26-2018, 11:28 AM   #4
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: 2011 Electric Precedent does nothing

Nope, that test just eliminated the OBC lockout being the cause of the problem.

Check the 15 amp fuse in the harness fuse holder near the controller 16-pin connector.
Sergio is offline   Reply With Quote
Old 06-26-2018, 02:08 PM   #5
Kenlhlp
Not Yet Wild
 
Join Date: Nov 2015
Posts: 70
Default Re: 2011 Electric Precedent does nothing

Fuse OK.
Kenlhlp is offline   Reply With Quote
Old 06-26-2018, 02:52 PM   #6
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: 2011 Electric Precedent does nothing

Do You get any voltage at the Key Switch when the Tow/Run switch is on Run?
Sergio is offline   Reply With Quote
Old 06-29-2018, 03:30 PM   #7
Kenlhlp
Not Yet Wild
 
Join Date: Nov 2015
Posts: 70
Default Re: 2011 Electric Precedent does nothing

Yes.

Re-checked the Forward/Reverse switch and it is ok. Re-checked the MCOR and it is ok. Works in another cart just fine.

Stumped..
Kenlhlp is offline   Reply With Quote
Old 06-30-2018, 12:23 PM   #8
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,169
Default Re: 2011 Electric Precedent does nothing

Jack the rear wheels up off of the ground and remove the controller access cover. Unplug the 16 pin connector from the controller.

At this point you need to check for every signal coming into the controller. Put your meter on 200V DC and place the negative probe on the main negative battery terminal.
With key switch on, F&R switch in forward, and tow/run switch in run, check for power on the grey wire, tan wire, and brown wire. You should have power on all three of these wires. If you don't, let us know which one.
TahoeDawgZ71 is offline   Reply With Quote
Old 07-03-2018, 01:51 PM   #9
Kenlhlp
Not Yet Wild
 
Join Date: Nov 2015
Posts: 70
Default Re: 2011 Electric Precedent does nothing

Have full battery voltage at all three wires.
Kenlhlp is offline   Reply With Quote
Old 07-03-2018, 04:41 PM   #10
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,169
Default Re: 2011 Electric Precedent does nothing

Check for power on pin 6, the solid green wire, with the key on, tow/run switch in run, f&r switch in forward, and accelerator pedal down.
TahoeDawgZ71 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Axle from a 2011 Precedent electric Golf Carts and Parts
2011 Club Car Precedent - Electric Golf Carts and Parts
2011 Precedent electric Club Car Heditates Electric Club Car
2011 Electric RXV Electric EZGO
2009-2011 Electric Precedent Maintenance and Service Manual Electric Club Car


All times are GMT -5. The time now is 08:55 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.