Driven Clutch Seized to the Shaft

Dreamer · 11-02-2011, 05:27 PM

I was looking over the clutches on my project cart and noticed the helix on the secondary clutch was broken. I then noticed there was no bolt holding the clutch to the shaft. The clutch is seized to the shaft and will not pull off by hand and does not turn on the shaft. The key ways are not lined up either.

Does anybody have any ideas on how I should go about getting this clutch off?

ckiguy · 11-02-2011, 08:01 PM

well dreamer if you have it seized, the key way is sheared off, and no reatineing nut, i think its time to give it some pursation! please rember it is brittle cast aluiniun and is its very easy to damage! but i think this is going to have to be replaced with a new one or a new used one! i dont think it is going to come off with out a fight!

Dreamer · 11-02-2011, 11:37 PM

Well I got it off. Anyone have a used one they want to part with. I destroyed 2 Harbor Freight Pullers and the clutch. Whoever put the thing on last must have been challenged.

11-02-2011, 05:27 PM	#1
Dreamer Not Yet Wild Join Date: Oct 2011 Posts: 15	Driven Clutch Seized to the Shaft I was looking over the clutches on my project cart and noticed the helix on the secondary clutch was broken. I then noticed there was no bolt holding the clutch to the shaft. The clutch is seized to the shaft and will not pull off by hand and does not turn on the shaft. The key ways are not lined up either. Does anybody have any ideas on how I should go about getting this clutch off?
Dreamer Not Yet Wild Join Date: Oct 2011 Posts: 15

11-02-2011, 08:01 PM	#2
ckiguy Bad *** Speller! Join Date: Oct 2009 Location: Columbus, Ohio Posts: 1,338	Re: Driven Clutch Seized to the Shaft well dreamer if you have it seized, the key way is sheared off, and no reatineing nut, i think its time to give it some pursation! please rember it is brittle cast aluiniun and is its very easy to damage! but i think this is going to have to be replaced with a new one or a new used one! i dont think it is going to come off with out a fight!

11-02-2011, 11:37 PM	#3
Dreamer Not Yet Wild Join Date: Oct 2011 Posts: 15	Re: Driven Clutch Seized to the Shaft Well I got it off. Anyone have a used one they want to part with. I destroyed 2 Harbor Freight Pullers and the clutch. Whoever put the thing on last must have been challenged.
Dreamer Not Yet Wild Join Date: Oct 2011 Posts: 15

Similar Threads
Thread	Forum
1 7/16 shaft clutch options	Big Block Talk!
1 1/2 shaft clutch?	Big Block Talk!
Ideas for extending driven shaft...	Gas Club Car
G2 driven clutch shaft broke off rear	Gas Yamaha
1in shaft clutch	Design Center

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum