08-22-2017, 05:22 PM | #1 |
Not Yet Wild
Join Date: Aug 2014
Posts: 18
|
96 ds Starts intermintently
Hi there guys. Im struggling to solve my issue. Here it is. My cart will not always start right off every time from a stop. I have to play with the gas pedal until it fires up. Some times more, sometimes less. Once it goes, it goes like a raped ape. The starter turns the motor fine, no belt slippage, but it just wont run. Once in a while a back fire, a little more often, a puff or two out through the air intake. Ive cleaned carb twice. Two new fuel filters. new spark plug. Tested battery, it good. Fresh tank of fuel. Pleeassssse, if anyone can help ill be so grateful. I don't have enough hair to keep pulling out! THANK YOU
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-22-2017, 05:56 PM | #2 |
Not Yet Wild
Join Date: Aug 2014
Posts: 18
|
Re: 96 ds Starts intermintently
Got it home playing around with it in maint mode. if I mash the pedal to the floor it wont fire, if I let off and slowly depress the pedal it WILL run. That's also when a get the air puff back through the air intake. pulled the plug after it sat and spun without firing for a full minute or more. it was dry
|
08-22-2017, 06:05 PM | #3 |
Not Yet Wild
Join Date: Aug 2014
Posts: 18
|
Re: 96 ds Starts intermintently
shot a little carb cleaner in the intake as it was sat in spun without turning over. the carb cleaner made it run, without playing with the pedal..... But I did disconnect the fuel line just before that, and it was pumping fuel
|
08-22-2017, 08:51 PM | #4 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 96 ds Starts intermintently
I know you said you cleaned your carb twice but your symptoms sound exactly like a plugged pilot jet did you pull it out and make sure it wasn't plugged and blow forced air through the passage?
|
08-22-2017, 09:05 PM | #5 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: 96 ds Starts intermintently
Check linkage all the way to carb.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Starts OK but | Gas EZGO | |||
05 STALLS out, starts-5',stops, starts-5', stops, etc | Gas EZGO | |||
94 ds starts sometimes | Gas Club Car | |||
Starts sometimes and then nothing! | Gas Yamaha | |||
G16 starts once but not a second | Gas Yamaha |