![]() |
![]() |
#1 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() played with cart 1992 club car runs slow messed around checking voltage and still runs slow all of a sudden speed up to 3/4 speed and then slowed back down any places to check to see if i need a v glide or a controller i have new battery that read out 36 volts
|
![]() |
![]() |
![]() |
|
![]() __________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
![]() |
#2 |
The Last Moja Morani
![]() ![]() Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
![]() if its only reading 36 volts thats not good........check each battery and load test each one...........as for v-glide you can open it up and see what the movable arm is doing......is it sliding from start to finish or stopping short......you,ll need to inspect it.......................................
![]() |
![]() |
![]() |
![]() |
#3 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() Opened v glide up it moves with out stoping start to finish what kind of electrical readings should I be getting at the v gilde and motor with gass pedal fully depressed ? And where should I take readings at to trouble shoot this problem I'm kinda lost
|
![]() |
![]() |
![]() |
#4 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() now found out that all batterys have 6.7 volts now load and under load 5.7 cart runs fine for 5 min+ then the cart starts to slow way down any other ideas ?
|
![]() |
![]() |
![]() |
#5 |
Happy Carting
![]() ![]() Join Date: Dec 2007
Location: Southern California
Posts: 73,963
|
![]() Usually if the cart starts out strong but weakens or slows after a short ride the batteries are suspect. Connect a hand held meter to the pack and let us know how low the pack voltage drops when she slows.
|
![]() |
![]() |
![]() |
#6 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() 5,7 is the lowest pack under load
|
![]() |
![]() |
![]() |
#7 |
Happy Carting
![]() ![]() Join Date: Dec 2007
Location: Southern California
Posts: 73,963
|
![]() Is it a resistor coil or ESC drive system?
How are you load testing? |
![]() |
![]() |
![]() |
#8 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() this cart has a controller no resistors and to load test i put the cart in front of a wall and press the gas down and hit the gas to the floor and then check each battery at 50% then 100% every time i try it i never get less than 5.7v
|
![]() |
![]() |
![]() |
#9 |
Not Yet Wild
Join Date: Apr 2012
Posts: 73
|
![]() Still need help guys
|
![]() |
![]() |
![]() |
#10 |
Medicare Recipient
![]() ![]() Join Date: Jun 2011
Location: West Michigan
Posts: 3,540
|
![]() . . check/clean all connections in Vglide including wiper arm and the contact points for wiper arm . . . otherwise, assuming batteries are good, you may be having controller or motor issues . . .
|
![]() |
![]() |
![]() |
|
Thread Tools | |
Display Modes | |
|
![]() |
||||
Thread | Forum | |||
77 3 wheeled golf cart running very slow | Gas EZGO | |||
Update on cart running slow not charging | Electric EZGO | |||
95 CC Running Slow | Electric Club Car | |||
Cart alternates from running fast to slow. | Gas Yamaha |