|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
01-14-2015, 12:33 PM | #1 |
Getting Wild
Join Date: Apr 2009
Posts: 137
|
RXV Front End Clunk
I have a 2010 EzGo RXV. All stock. The front end clunks when I hit bumps. What could it be? What should I start looking at? Thank You.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-14-2015, 01:02 PM | #2 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: RXV Front End Clunk
Bushings.
Lift cart by placing jack under center of front. grasp wheel at top and bottom and apply twisting force to top and bottom of wheel(not to turn wheel) you will probably see movement at lower a arm bushings. 2 sets on inner a arm (near center of cart) one at outer a arm (near wheel). These go bad every few years and in wet areas, you will need to replace the bolt as they rust and get rough or worn down. These bushings are hard material, soft rubber bushings are not acceptable subs. for them. also check tie rod ends and steering box. Bushings on rack can also go bad. Probably lower-outer a frame bushings. Good luck !! Let us know what you find. |
01-14-2015, 01:13 PM | #3 |
Getting Wild
Join Date: Apr 2009
Posts: 137
|
Re: RXV Front End Clunk
Thanks again for all of your help. You have helped me so much on here. Someday Maybe I can do something for you or pay it forward to someone else. Thank you so much.
|
01-14-2015, 01:28 PM | #4 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,177
|
Re: RXV Front End Clunk
I ditto the bushings. Outer ones next to the shock lower..
|
01-14-2015, 06:23 PM | #5 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: RXV Front End Clunk
Hi rhino -- thanks for friend request.
I cannot do friend/private messages due to agreement with owner of shop where i work. All my info /communications stay out in the open. Thank you. Still a friend ! |
01-14-2015, 06:30 PM | #6 |
Getting Wild
Join Date: Apr 2009
Posts: 137
|
Re: RXV Front End Clunk
No worries. I understand. If your ever in California let me know. Hopefully someday I can do something for you. Thanks again.
|
01-15-2015, 04:28 PM | #7 |
Gone Wild
Join Date: Aug 2014
Location: Duncan Corners
Posts: 905
|
Re: RXV Front End Clunk
Keep us posted !!!
Let us know what you find !! Pics if its weird or interesting!!! Thats thanks enough. |
01-30-2015, 10:04 PM | #8 |
Not Yet Wild
Join Date: Aug 2013
Location: Madison AL
Posts: 64
|
Re: RXV Front End Clunk
RXV Outer lower A Arm Bushings. Replaced mine and what a difference.
|
02-05-2015, 07:54 PM | #9 |
Gone Wild
Join Date: Jan 2013
Location: Saint Petersburg, FL
Posts: 2,089
|
Re: RXV Front End Clunk
Did you find the clunking noise?
I had a clunking noise on my cart. It was my LED lights.... They were mounted to the front cross member (right word?) and when I hit a bump the cross member would go up towards the body and the tip of the lights would hit a decorative piece of plastic... The plastic would bend then CLUNK over the lights. |
02-29-2016, 09:29 PM | #10 |
Not Yet Wild
Join Date: Nov 2014
Location: Seal Beach, Ca
Posts: 5
|
Re: RXV Front End Clunk
Thanks everyone for the help and input. I think this is my source of my clunking as well and have ordered new Bushings and Carrier Tubes..
Question on replacing them: Should the parts be installed using any type of grease/lube or just dry fit...? Thanks again |
|
|
Similar Threads | ||||
Thread | Forum | |||
clunk noise when starting | Gas Club Car | |||
Who'd-a-thunk (clunk) | Gas EZGO | |||
EZ Go Rear Clunk - What to do? | Electric EZGO | |||
82 G1 starting to clunk | Gas Yamaha |