Ezgo starter/generator weak

LukeL · 02-03-2018, 08:35 AM

The starter/generator in my 1990 3pg ezgo is not strong enough to start the engine. I’ve replaced the battery, checked all cables, and used a jumper cable.

It turns a little bit, and if you hold the gas for about 30 seconds, it will usually start to turn over.

Do I need to replace the starter?

Sent from my iPhone using Tapatalk

cart around · 02-03-2018, 08:43 AM

Pull the rubber plugs, and check the brushes. There are wear lines marked on them.

02-03-2018, 08:35 AM	#1
LukeL Gone Wild Join Date: Jun 2017 Location: Savannah, GA Posts: 6,539	Ezgo starter/generator weak The starter/generator in my 1990 3pg ezgo is not strong enough to start the engine. I’ve replaced the battery, checked all cables, and used a jumper cable. It turns a little bit, and if you hold the gas for about 30 seconds, it will usually start to turn over. Do I need to replace the starter? Sent from my iPhone using Tapatalk

02-03-2018, 08:43 AM	#2
cart around Test before replacing Join Date: Aug 2013 Location: Ohio side of the Pennsylvania border. Posts: 3,495	Re: Ezgo starter/generator weak Pull the rubber plugs, and check the brushes. There are wear lines marked on them.

Similar Threads
Thread	Forum
Ezgo starter generator	Gas EZGO
WTB Starter generator for EZGO	Golf Carts and Parts
88 ezgo gas starter/generator stuck in starter mode	Gas EZGO
EZGO starter / generator	Golf Carts and Parts
Ezgo starter/generator	Golf Carts and Parts

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum