|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-17-2016, 08:24 PM | #1 |
Not Yet Wild
Join Date: Dec 2016
Posts: 8
|
1994 ezgo gas rear end problem
the rear tires do not turn in forward or reverse. the shaft turns by the rear flywheel going into the transmission.could this be wore out spines in the rear hubs.the cart has had a loud roaring sound for about a month.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-17-2016, 09:04 PM | #2 |
Gone Wild
Join Date: Feb 2008
Location: Brooklyn, Michigan "Home of M.I.S."
Posts: 3,666
|
Re: 1994 ezgo gas rear end problem
Could be, is the nut holding the hub on the axle spinning?
|
12-18-2016, 10:59 AM | #3 |
Not Yet Wild
Join Date: Dec 2016
Posts: 8
|
Re: 1994 ezgo gas rear end problem
i have not got that far yet. its too cold out to mess with it outside right now.tuesday i will pull the wheels off and see.
|
12-18-2016, 11:13 AM | #4 |
Getting Wild
Join Date: Feb 2014
Location: Superior Wi
Posts: 137
|
Re: 1994 ezgo gas rear end problem
to check it leave the wheels on the ground so there is resistance then check both sides to see if the axle is turning when trying to go.
|
12-18-2016, 01:17 PM | #5 |
Gone Wild
Join Date: Dec 2010
Location: Woodstock,GA
Posts: 1,088
|
Re: 1994 ezgo gas rear end problem
The 1st thing I would do is
make sure the shift cables are actually turning the shaft going into the trans/rear end. And it is engaging the gears. Then I would jack it up and see if the wheels will turn without a load on them. Mark the axle nuts see if they are turning. You said it was making a roaring noise before, that most likely would indicate a gear issue. good luck and let us know what you find. |
12-18-2016, 01:35 PM | #6 |
Not Yet Wild
Join Date: Dec 2016
Posts: 8
|
Re: 1994 ezgo gas rear end problem
i have already check the shifter at the rear end it is working proper.
|
12-19-2016, 01:30 PM | #7 |
Not Yet Wild
Join Date: Dec 2016
Posts: 8
|
Re: 1994 ezgo gas rear end problem
the right side hub is toast no splines. the left side is fine.going to pick one up now about 1 hour drive.
|
12-19-2016, 02:15 PM | #8 |
Gone Wild
Join Date: Feb 2008
Location: Brooklyn, Michigan "Home of M.I.S."
Posts: 3,666
|
Re: 1994 ezgo gas rear end problem
|
12-19-2016, 07:57 PM | #9 |
Not Yet Wild
Join Date: Dec 2016
Posts: 8
|
Re: 1994 ezgo gas rear end problem
i got the new hub on the wheels turn now.. drives alright but now i got a new problem. the secondary clutch has a wooble in it now.the bolt come out a while back. after putting a new bolt and washer on it i noticed the wooble.a guy told me the splines were wore on the clutch and if i dont replace it the bolt could break off into the shaft.thats about $200. any thoughts
|
12-20-2016, 11:34 AM | #10 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: 1994 ezgo gas rear end problem
*sometimes* the clutch will shift a bit on the shaft if the bolt falls out, I would try pulling the clutch off and rotating it 45 degrees or so then tighten it down again, chances are if the shaft and/or clutch aren't *too* damaged it just may center itself up again and be fine as long as You keep a bolt in there, LOL
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
ezgo 1994 medalist rear body and the bagwell complete | Golf Carts and Parts | |||
1994 Gas EZGO Marathon problem | Gas EZGO | |||
1994 ezgo problem will not go! | Electric EZGO | |||
1994.5 ezgo medalist rear end question | Electric EZGO | |||
1994 EZGO Problem "Slipping" | Electric EZGO |