03-09-2017, 03:30 PM | #1 |
Getting Wild
Join Date: Nov 2011
Location: ohio
Posts: 119
|
Express S4
Does anybody know how to adjust governor on 2017 ez go express S4 gas cart?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-09-2017, 04:41 PM | #2 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,173
|
Re: Express S4
Found a write up I did on how I adjusted mine..
Take the throttle cable out of the bracket, loosen the 10mm nut on the gov bracket and get it where when the pedal is pushed it will start and idle. Then loosen the nut/bolt holding the governor to the shaft and make sure it is spun all the way against its backstop. Mine wasn't. Then hold the throttle against idle, the gov against its stop and tighten the 10mm nut. Now hook your cable back up and tweak. Mine with 21 inch tires runs 26 at 4k rpm |
03-09-2017, 04:57 PM | #3 |
Getting Wild
Join Date: Nov 2011
Location: ohio
Posts: 119
|
Re: Express S4
Do you have the express?
|
03-10-2017, 07:46 AM | #4 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,173
|
Re: Express S4
Nope. Mine was an RXV but same governor setup.
|
03-10-2017, 08:25 AM | #5 |
Getting Wild
Join Date: Nov 2011
Location: ohio
Posts: 119
|
Re: Express S4
I was looking for rear flairs and can't find then. Thought you might know? If you do let me know. Thank you,Rich
|
03-10-2017, 09:38 AM | #6 |
Not Yet Wild
Join Date: Dec 2015
Location: Tampa
Posts: 14
|
Re: Express S4
|
03-10-2017, 11:08 AM | #7 |
Getting Wild
Join Date: Nov 2011
Location: ohio
Posts: 119
|
Re: Express S4
I checked my throttle and it is opening all the way setting still. It is going about 17 mph. If I reset it like you said will it make a difference? I will check out the flares. Thank you,Rich
|
03-10-2017, 02:52 PM | #8 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,173
|
Re: Express S4
The adjustment is made by adjusting the cable where it goes into the governor. The farther the end of the cable is away from the spring the faster it will go. Be careful not to adjust it too far as it can cause the engine valves to float which is bad.
|
03-10-2017, 03:06 PM | #9 |
Getting Wild
Join Date: Nov 2011
Location: ohio
Posts: 119
|
Re: Express S4
I ordered a tack for it today and then I will play with the governor. Is 4000 rpm about the limit? This is a 401 cc engine. Still working on the flares. Thanks
|
03-10-2017, 03:30 PM | #10 |
Not Yet Wild
Join Date: Dec 2015
Location: Tampa
Posts: 14
|
Re: Express S4
I'm a dealer. I can get you the flares if you want. PM me if you're interested and I'll price them for you.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
express S4 | Electric EZGO | |||
Express s4 brushguard | Gas EZGO | |||
2012 EZ-GO Express S4 | Gas EZGO | |||
St Express | Lifted Golf Carts | |||
2008 Ez-Go ST Express | Golf Carts and Parts |