|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-16-2011, 01:14 PM | #1 |
Not Yet Wild
Join Date: Oct 2011
Location: South Carolina
Posts: 2
|
Ezgo Battery charge issues
I have a 2008 Ezgo Electric Golf Cart. It charges fine and runs great for about 4 holes then gets sluggish fast! almost did not make it home after 9 holes.
I tested my battery's volts and tested with hydrometer. results after charging them overnigh: Batt 1 6.36 volts all three cells test in the good range on Hydrometer. Batt 2 6.31 and two cells tested good one cell tested fair range. Batt 3 6.32 all cells tested good on Hydrometer. Batt 4 6.38 all cells tested good on Hydrometer. Batt 5 6.34 all cells tested good on Hydrometer. Batt 6 6.21 all cells tested good on Hydrometer. Can I clean them using that Epson salt method to improve my power and restore my batteries? Anyone have any suggestions? I really do not want to buy new batteries if I can save these. Thanks!!!!! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-16-2011, 03:18 PM | #2 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Ezgo Battery charge issues
Quote:
First, get a hydrometer that reads Specific Gravity to 3 decimal places. (IE: 1.277 for a fully charged cell 1.258 for a 90% SoC) At most, only all three cells in the batteries with a 98% or higher SoC (State of Charge) should have test "Good" and there might be a few individual cells in the remaining batteries with a SG of 1.258 or greater. Some people are for the "Snake Oil" battery restoration techniques, some are against it. Personally, I'm against it. Wet cell lead acid batteries work on lead (alloys) and sulfuric acid (H2SO4) diluted with pure water (H2O), anything else is a contaminant and interferes with the chemical processes. To get a better idea of how good/bad your batteries are, measure the terminal voltage after you've ran the cart two or three miles. Your performance and run time are limited by the weakest battery, so you're starting out with about a 70% charge. Battery #6 is probably beyond redemption, but you might be able to replace it with a good used battery about the same age and delay buying a new set for a couple months. Good luck, John |
|
10-16-2011, 05:33 PM | #3 |
Not Yet Wild
Join Date: Oct 2011
Location: South Carolina
Posts: 2
|
Re: Ezgo Battery charge issues
Hey,
Thanks alot for the information! Since I'm a female golf cart mechanic in training (as my husband calls me) I'm trying to learn as much as I can to fix any problem that we have. I really appreciate these forums, they help out alot!! I may try the "Snake Oil" treatment just for fun..can't hurt it if I have to have new batteries anyway! LOL I'll send you a report if I decide to try it. :) Cheryl |
10-17-2011, 05:17 PM | #4 | |
Gone Wild
Join Date: Oct 2008
Location: Southwest Georgia
Posts: 610
|
Re: Ezgo Battery charge issues
Quote:
http://inoxlube-usa.com/category/golf-cart/ |
|
10-17-2011, 07:31 PM | #5 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: Ezgo Battery charge issues
Welcome to BGW
here read this, and then see if you want to do it, http://www.buggiesgonewild.com/elect...batteries.html it can be VERY dangerous working with batteries, you dont want any battery acid on your skin. or in your eyes, make sure IF you try this, read alot more about it, before you try it, and get all the proper gear to attempt this, safty frist http://www.buggiesgonewild.com/elect...batteries.html |
|
|
Similar Threads | ||||
Thread | Forum | |||
EZGO Textron 36 Volt Battery Charger will not charge | Electric EZGO | |||
EZgo Total Charge battery charger | Electric EZGO | |||
Electric Ezgo Battery Charge (Batteries or controller?) | Electric EZGO | |||
ezgo starter generator wont charge battery but will turn motor | Gas EZGO | |||
EZGO Battery Charging Issues | Electric EZGO |