|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-29-2013, 08:26 AM | #1 |
Gone Wild
Join Date: Jun 2013
Posts: 155
|
Polarity and voltage on Key Ignition on 94 CC
I've searched around but can't get a straight answer. I need to know what is the polarity and Voltage that goes across the key/ignition switch on a 1994 Club Car DS - 36v. Some say it negative polarity but yet my old volt meter reads it as positive and its like 12v or something not even 36
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-29-2013, 09:40 AM | #2 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Re: Polarity and voltage on Key Ignition on 94 CC
It's just a hot 36v wire that goes to one side of the switch and when the key is turned it allows voltage to flow to the other side. Input wire comes from positive on battery to f/r switch then to key switch. When key is turned positive voltage flows through key switch to microswitch on f/r and then to small post on solenoid.
In short it's 36v positive |
07-29-2013, 09:44 AM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Polarity and voltage on Key Ignition on 94 CC
Early carts had pack negative thru the key switch. Is it safe to say the controller carts have pack + thru the key and resistor coil carts have - ?
|
07-29-2013, 10:12 AM | #4 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Re: Polarity and voltage on Key Ignition on 94 CC
Wiring is different then I explained if it has controller but it's still positive 36v on 94
|
07-29-2013, 10:46 AM | #5 |
Gone Wild
Join Date: Jun 2013
Posts: 155
|
Re: Polarity and voltage on Key Ignition on 94 CC
Yeah I have resistors not controller. Am I still positive or negative ?
|
07-29-2013, 10:59 AM | #6 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Re: Polarity and voltage on Key Ignition on 94 CC
Resistors are still positive. The only one I am not sure about is 5 solenoid carts cause it's been a while but even on those I can't see why they wouldn't be positive to key.
|
07-29-2013, 11:16 AM | #7 |
Gone Unrestrained
Join Date: Aug 2008
Location: South Florida
Posts: 1,300
|
Re: Polarity and voltage on Key Ignition on 94 CC
I have been trying to figure this out as well. I have an 85 club car with two posts. Its a five solenoid resistor cart. I have tested the key switch and don't have any voltage at all. It also has two posts. Cart only runs with key on....Is yours the same setup?
|
07-29-2013, 11:20 AM | #8 |
Gone Wild
Join Date: Jun 2013
Posts: 155
|
Re: Polarity and voltage on Key Ignition on 94 CC
I have one solenoid and resistors. Cart runs with key ON . Last I checked with meter I too was getting odd reading that's why I came here for help. Don't want burn my cart out installing a four prong digital battery meter.
|
07-29-2013, 11:25 AM | #9 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Re: Polarity and voltage on Key Ignition on 94 CC
If your cart runs with key on the switch is bad with contacts shut. Put a DVM on ohms and check it with leads on both terminals you should get reading with key switch in on position only
PS... Just checked schematic and 5 solenoid cart is negative to key switch |
07-29-2013, 11:56 AM | #10 |
Gone Wild
Join Date: Jun 2013
Posts: 155
|
Re: Polarity and voltage on Key Ignition on 94 CC
I thought that's the whole perpose to have the car run when the ignition key is in the "ON" position and not run when it's in the "off" position. So you lost me by saying my switch is bad if its doing its job. I just new to know what polarity is running through it.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Chrysler ignition module and voltage regulator on g2 | Gas Yamaha | |||
DOH! EZGO Battery polarity connected backward to PDS controller! | Electric EZGO | |||
Switched Polarity after putting motor back in | Electric EZGO | |||
Voltage Regulator Polarity? | Gas EZGO | |||
? Reversed Polarity on Battery? | Electric golf carts |