lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 06-11-2020, 08:27 AM   #1
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default 82 ezgo wont start have spark fuel air help please

I have a 1982 EZGO 2 stroke running ran a while ago the guy I got it from said he took it in to get it serviced and it's never ran after it was serviced they quoted him a bunch of other parts I found the electrical wire drawing on the control switch to go forward and backwards somebody had mixed up one of the wires I got it running it ran good then died I put a new coil pack for the ignition have clean the carburetor 2 or 3 times installed new fuel and fuel filter will not fire up and run can crank and crank have gas on the other side spark plug gets wet got a brand new spark plug to swap back and forth help me I am lost
306munro is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 06-11-2020, 08:33 AM   #2
cart around
Test before replacing
E-Z-GO
 
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,309
Default Re: 82 ezgo wont start have spark fuel air help please

Check for spark first thing.

Ran good for how long before it died? Did it pop, or backfire?

I'm going to bed. Will be back later.
cart around is online now   Reply With Quote
Old 06-11-2020, 08:49 AM   #3
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default Re: 82 ezgo wont start have spark fuel air help please

It ran good for about 20 minutes or so it really was ripping around decently I come back and yes it popped and backfired as it pulled into the driveway and died it does have spark I'm just guessing maybe I'm not getting good enough Spark I tried another aftermarket coil pack to the spark plug still no change watch a spark at the plug have exhaust off cylinder looks good little bit of scoring on one side rings tlr8 can still feel them on your fingers not stuck
306munro is offline   Reply With Quote
Old 06-11-2020, 09:18 AM   #4
cart around
Test before replacing
E-Z-GO
 
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,309
Default Re: 82 ezgo wont start have spark fuel air help please

I'm thinking popped crankshaft seal.
cart around is online now   Reply With Quote
Old 06-11-2020, 09:59 AM   #5
Lochlin
Gone Wild
 
Join Date: May 2011
Location: Pittsburgh
Posts: 2,751
Default Re: 82 ezgo wont start have spark fuel air help please

Quote:
Originally Posted by cart around View Post
I'm thinking popped crankshaft seal.
X2 on the crank seal.

Check your compression to make sure that you didn't blow your head gasket as well.
Lochlin is offline   Reply With Quote
Old 06-11-2020, 10:42 AM   #6
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default Re: 82 ezgo wont start have spark fuel air help please

A crank seal you figure? Dang on the head side or you mean like the whole case seal
306munro is offline   Reply With Quote
Old 06-11-2020, 10:45 AM   #7
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default Re: 82 ezgo wont start have spark fuel air help please

It seems to have compression sucks hard on the carb side and blows out good with spark plug out and the engine is laboured when spark plug is in how hard should it be to turn over by hand at the pulley
306munro is offline   Reply With Quote
Old 06-11-2020, 10:59 AM   #8
Dabble Inn
Nincompoop Club Member
 
Dabble Inn's Avatar
E-Z-GO
 
Join Date: Jun 2016
Location: Idaho
Posts: 1,079
Default Re: 82 ezgo wont start have spark fuel air help please

Here's a pic of a crank seal on the clutch side, there's another one on the flywheel side just like it
Attached Images
File Type: jpg 20170712_155144_LI.jpg (186.1 KB, 0 views)
Dabble Inn is offline   Reply With Quote
Old 06-11-2020, 12:23 PM   #9
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default Re: 82 ezgo wont start have spark fuel air help please

Oh okay so I dont need to pull the whole engine for it to be replace? I've never pulled a clutch off what's the tools needed if I dont have I'll pick up
306munro is offline   Reply With Quote
Old 06-11-2020, 12:24 PM   #10
306munro
Not Yet Wild
 
Join Date: Jun 2020
Posts: 14
Default Re: 82 ezgo wont start have spark fuel air help please

Its firing here now today bangs and pops lol wasnts to start but yeah
306munro is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
3pg with spark and fuel but won't start! Gas EZGO
Has spark & fuel but won't start Gas Club Car
EZ GO Marathon - 4 stroke has spark and fuel but wont start Gas EZGO
G9 No start, fuel, no spark Gas Yamaha
i have spark and fuel but wont go Gas EZGO


All times are GMT -5. The time now is 10:07 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2023, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.