|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
|
10-15-2018, 09:14 PM | #1 |
Not Yet Wild
Join Date: Oct 2018
Posts: 2
|
2011 Gas Club Car - Will not start when depressing gas pedal
We just recently purchased a 2011 Gas Club Car. After only having it for a week, my daughter was driving it around, and everything was running fine. She stopped very briefly to use her phone and when she pressed the gas pedal to resume, it would not start/run/move. Battery does charge, but with a multimeter on the battery while pressing the gas, voltage only reads 9 volts. I'm thinking starter/generator but I've heard thats somewhat uncommon. Any other ideas? Thanks in advance.
|
10-15-2018, 09:47 PM | #2 |
Getting Wild
Join Date: Jul 2018
Location: Central Texas
Posts: 107
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
We had similar issues, which turned out to be caused by the voltage regulator. Which motor does yours have?
|
10-15-2018, 10:53 PM | #3 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
How old is the battery? If it only shows 9v it’s dead. You can charge it and see how long it holds a charge. Test the starter generator output after charging the battery, but the battery is probably in need of replacement.
|
10-16-2018, 05:30 PM | #4 |
Not Yet Wild
Join Date: Jul 2012
Location: Galveston
Posts: 3
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
We had the exact same problem. Drove off the trailer. Stopped. Put cart in reverse and the backup beeper got faint, and no go. Headlights worked, USB port, speaker, all that so we couldn't believe it was the battery, till we replaced it and away we went.
|
10-16-2018, 06:18 PM | #5 |
Not Yet Wild
Join Date: Jul 2014
Location: Middle Georgia
Posts: 60
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
Yup 9vdc on a 12vdc batt is D E A dead!!
What's the battery year? (should have a decal on it or dated somehow) As suggested, give it a good slow charge recommend 2amp setting if you have that option. Then you can test proper S/G output. Lights, USB plugs, etc will light fine sitting since they don't draw too many amps. Trying to get the engine spooling draws a lot of amps, this what's happening. Sent from my XT1635-01 using Tapatalk |
03-17-2019, 12:33 PM | #6 |
Not Yet Wild
Join Date: Oct 2018
Posts: 2
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
Ok, sorry for being MIA. Since last post, I had battery tested with snap-on battery tester and tested good. Since then, I have replaced starter generator, neutral lockout switch, solenoid, micro switches, throttle tric and key switch. Checked all grounds I could find, cleaned all wire ends and rusty parts. If I jump across the 2 big posts on solenoid it will turn over, but no spark. Kawasaki engine. Thanks everyone.
|
03-17-2019, 08:39 PM | #7 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 2011 Gas Club Car - Will not start when depressing gas pedal
That’s all way beyond what needed to be replaced. Did you check the fuse in the electrical box?
Fuse gives 12v to the key switch on the red wire. Key switch ON supplies 12v to Blue wire to the Solenoid. The combination of the throttle cam switch and FNR limit switch supply ground for the Orange wire on the solenoid. This circuit is grounded through key switch through the white wire on the M+ terminal on the switch, and then through the Black wire from the M- terminal to the frame. With key On check for 12v reaching the solenoid on the Blue wire. Jump the small post with the Orange wire to frame ground. The solenoid should click and the starter motor should start turning. If it does not, the solenoid is bad, or there is a poor connection from battery to cable to the solenoid. If the above test makes the engine crank over, there is a wire problem between the solenoid , throttle cam limit switch, FNR limit switch, and key switch. Or the key switch does not have good ground for the M- terminal. A bad ground circuit will show 12v up to the point of the poor connection, so with key On, simply check for 12v on the terminals at each limit switch. Be sure to actuate the throttle and the FNR lever to make sure the switches close. If one limit switch only shows 12v on one side even when you actuate the switch, that switch may be bad or may have a poor connection. If you have 12v present all the way to the key switch on the white wire, the key switch has a bad contact or has no ground on the Black wire. Wire diagram for your cart is here: http://www.buggiesgonewild.com/gas-c...ml#post1251631 If that’s an aftermarket starter generator, odds are good it will cause you more grief down the road. Many aftermarket units are cheap and fail in spectacular fashion. |
|
|
Similar Threads | ||||
Thread | Forum | |||
When slightly depressing gas pedal motor is at full speed | Electric EZGO | |||
Long delay to start after depressing pedal - Yamaha G1 | Gas Yamaha | |||
96 club car won't always start when pressing pedal | Gas Club Car | |||
2011 Club Car Precedent Go/accelerator Pedal Issue | Electric Club Car | |||
1993 club car ds....no start with pedal | Gas Club Car |