lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-07-2016, 10:43 AM   #1
terrykcook
Not Yet Wild
 
Join Date: Dec 2014
Posts: 3
Default 1995 gas club car that will not shut off

It would not run at first so I replaced the solenoid, starter and voltage regulator and it started and ran fine then about a week later it was running and would not shut off so I replaced all four micro switches now it will crank and run if you wiggle the forward reverse lever but it will not shut off unless I disconnect the battery cable if I put it in the neutral position the engine will rev up when I depress the go pedal.
terrykcook is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 09-07-2016, 11:09 AM   #2
meimk
Gone Wild
 
meimk's Avatar
Club Car
 
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,826
Default Re: 1995 gas club car that will not shut off

Check / clean / tighten all your grounds. Pay particular attention to the white / black wire that runs along the clutch side of the engine, but also the "main" ground to the frame rail next to the battery. The keys switch and/or combination of micro switches should ground the ignition spark to shut it down.
meimk is offline   Reply With Quote
Old 09-10-2016, 06:21 PM   #3
terrykcook
Not Yet Wild
 
Join Date: Dec 2014
Posts: 3
Default Re: 1995 gas club car that will not shut off

I had time to work on it today and found that the new solenoid that I had just installed had shorted out and was keeping the starter spinning all the time until I disconnected the positive battery cable.
terrykcook is offline   Reply With Quote
Old 09-10-2016, 06:43 PM   #4
terrykcook
Not Yet Wild
 
Join Date: Dec 2014
Posts: 3
Default Re: 1995 gas club car that will not shut off

Could some one supply me with a color code wiring diagram for a 1995 gas club car so I can make sure all the micro switches are wired correctly?
terrykcook is offline   Reply With Quote
Old 09-11-2016, 06:42 AM   #5
lockman1
What the ....?
 
lockman1's Avatar
Club Car
 
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,929
Default Re: 1995 gas club car that will not shut off

Post #6 in the wiring diagram "sticky"... it's for a 93-94 but, it's the same for your 95!
(actually... not much has changed for any of them!)

Click...>>> http://www.buggiesgonewild.com/gas-c...-diagrams.html
lockman1 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Club car shut off issue Gas Club Car
07 club car will not shut off Gas Club Car
95 club car will not shut off Gas Club Car
95 Club Car DS Starter does not shut off Gas Club Car
99 Club Car charger won't shut off Electric Club Car


All times are GMT -5. The time now is 08:59 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.