lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas golf carts > Gas Columbia ParCar


Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-23-2015, 05:01 AM   #1
backroadking
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default gas is spitting come out carb

I just bought a columbia 3 wheel golf cart. I believe its a 1984 ( serial number 3B 10509 C4) when i got it it would run on flat ground but could not make it up a hill. I replaced the drive belt, starter/gen belt, spark plug, fuel filters.( there was a filter in the impulse line to crankcase?) and i drained the fuel tank and refilled with 100:1 ratio. Its been running worse since. I now have fuel spitting out the carb, even after i cleaned it. I closed the float up alittle and have thr needle out about a 1/2 of turn now. It will startand will drive about 20feet then fall flat on its face and have to push it back because it will not have enough rpm to move it. Ant help or advise would be appreciated.
Thanks in advanced.
backroadking is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-23-2015, 05:05 AM   #2
backroadking
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default Re: gas is spitting come out carb

I looked at the reed valve and they look good to me? I also see gass in the impulse filter?
backroadking is offline   Reply With Quote
Old 07-31-2015, 04:22 PM   #3
Spicyunicorn
Gone Wild
Yamaha
 
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
Default Re: gas is spitting come out carb

gas spitting out of carb is common symptom of bad reads http://www.golfcartcare.com/Merchant...ory_Code=hreed theres a link might be worth trying new leaf also check and make sure exhaust is clear and no restrictions
Spicyunicorn is offline   Reply With Quote
Old 08-04-2015, 04:43 AM   #4
backroadking
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default Re: gas is spitting come out carb

Thank you for the reply,
When i went to that web site I read about the read plate assy and is said, A slight gap between the leaf and plate is normal. When i hold the reed plate up and shine a flashlight from the bottom I see a slight gap between the reed valve leaf and plate. Does that sound normal? Sorry if im not understanding the question.
backroadking is offline   Reply With Quote
Old 08-04-2015, 12:43 PM   #5
Lochlin
Gone Wild
 
Join Date: May 2011
Location: Pittsburgh
Posts: 2,534
Default Re: gas is spitting come out carb

If all of the reed leaves are there it's probably ok.

There really shouldn't be any gas leaking from the carb in any event. At worst, gas will seep toward the air cleaner to carb connection and leak there. If it's leaking after that point you may need a carb rebuild.

I suspect crank seals too as you may not have enough vacuum to pull the fuel through to your engine. If you only have your fuel adjustment out 1/2 turn your cart should be begging for more fuel rather than leaking it from the carb.
Lochlin is offline   Reply With Quote
Old 08-04-2015, 12:46 PM   #6
Lochlin
Gone Wild
 
Join Date: May 2011
Location: Pittsburgh
Posts: 2,534
Default Re: gas is spitting come out carb

Oh, the filter on the vacuum line is not supposed to be there. I am not sure it would affect performance as it's mostly air in that line anyway but the only filter should be between the gas tank and the fuel pump.
Lochlin is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas golf carts > Gas Columbia ParCar


Thread Tools
Display Modes


Similar Threads
Thread Forum
1991 ezgo spitting gas out carb into air filter Gas EZGO
96 txt gas spitting out gas? Gas EZGO
97 ezgo spitting gas out of the carb Gas EZGO
4 stroke - spitting gas thru carb - the finale! Gas EZGO
Fuel spitting out of carb and into aircleaner Gas Club Car


All times are GMT -5. The time now is 02:56 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.