lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-17-2009, 02:32 PM   #1
Demonical
Not Yet Wild
 
Join Date: Jul 2009
Posts: 2
Default '94 Club Car flooding

I have a 1994 Club Car and yesterday it started flooding for some reason. It has never done this before; the gas smell from the engine was quite noticeable.

I could get it to run if I disconnected the fuel line to the carb and turned it over enough to burn off the XS fuel, then it would run. It would stay running, once I had it going, but every time I stopped it, it would then flood and would not restart until I unhooked the fuel line again....

So what should I do?

I think there is just one small screw that I can adjust?

Should I also change the spark plug?



Btw, Howdy, I am Jim a golf-aholic from Alberta, Canada.
Demonical is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-17-2009, 04:23 PM   #2
hotmomma
Wildly Wicked!
 
hotmomma's Avatar
E-Z-GO
 
Join Date: May 2009
Location: TEXAS BABY!
Posts: 1,955
Default Re: '94 Club Car flooding

Welcome Jim! Look at the spark plug first to see if it's burnt..(black and check the tip also) if and when you do change it make sure you use the right gap size for your cart. There is an inlet valve that might be dirty and the float may need to be readjusted also. Check the air filter and the fuel filters too they may need to be changed also. Good Luck!
hotmomma is offline   Reply With Quote
Old 07-17-2009, 05:17 PM   #3
Demonical
Not Yet Wild
 
Join Date: Jul 2009
Posts: 2
Default Re: '94 Club Car flooding

So what would be the correct spark plug gap?
Demonical is offline   Reply With Quote
Old 07-17-2009, 05:52 PM   #4
scottyb
go to cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 70,722
Default Re: '94 Club Car flooding

Sounds to me like you may have a little piece of chit in the needle seat valve of the carburetor float... may be time for you to disassemble and clean the carb. I like to use carb cleaner with the little spray nozzle in every orifice until. Spray until you can see it coming out somewhere freely. It only takes one grain of stuff to screw up the float seat.... Be careful with the gasket and rubbers. Wear safety goggles when spraying into holes with the cleaner. Good luck
scottyb is offline   Reply With Quote
Old 07-17-2009, 06:15 PM   #5
roady89
nimda
Club Car
 
Join Date: Jun 2007
Posts: 13,023
Default Re: '94 Club Car flooding

Stuck needle/float bad, carb flooding. Clean crap out of carb as scottyb suggested. Check float for holes.
roady89 is offline   Reply With Quote
Old 07-17-2009, 06:18 PM   #6
scottyb
go to cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 70,722
Default Re: '94 Club Car flooding

Quote:
Originally Posted by roady89 View Post
Stuck needle/float bad, carb flooding. Clean crap out of carb as scottyb suggested. Check float for holes.
THe old sinking float It is always bad when you pull the float and it has to drain ......
scottyb is offline   Reply With Quote
Old 07-17-2009, 07:32 PM   #7
sickcraft
Not Yet Wild
Club Car
 
Join Date: Apr 2009
Posts: 62
Default Re: '94 Club Car flooding

I agree with Scotty. I had the same exact problem and it was float needle. I had to cleaned the carb 4-5 times before it stopped. I also replaced the fuel line and filter.
sickcraft is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G1 Flooding Bad Gas Yamaha
G1 Flooding? Gas Yamaha
g1 flooding Gas Yamaha
G1 Flooding Gas Yamaha
EZ Go flooding out Gas EZGO


All times are GMT -5. The time now is 03:18 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.